Professional Documents
Culture Documents
DQ Single Phase
DQ Single Phase
DQ Single Phase
ISSN 2091-2730
Single Phase d-q Transformation using as indirect Control Method for Shunt
Active Power Filter
Sachi Sharma1
1
Abstract A single-phase shunt active power filter is used mainly for the elimination of harmonics in single-phase AC networks. In
this paper a single-phase shunt active power filter based on, an indirect control technique is designed and simulated. This control
technique is achieved by phase shifting the input signal(voltage/current) by /2.The overall action of the shunt active power filter to
eliminate the harmonics created by a non-linear load on the source side is discussed in this paper and the output of the shunt active
power filter is verified using MATLAB/Simulink software.
1. Introduction
Because of the tremendous advantage of power electronic based devices/equipment they play a vital role in the modern power
processing .As a result these devices/equipment draws non-sinusoidal current from the utility side due to their nonlinearity .So in
addition to the reactive power supply a typical distribution system has to take care of the harmonics also[C]. These power quality
concerns made the power engineers to think about the devices which reduces the harmonics in the supply line [E,F].Such devices are
known as active power filter/power conditioners which are capable of current/voltage harmonic compensation. Active power filters
are classified into shunt , series and hybrid active power filters which can deal with various power quality issues [A,E]. One of the
major advantage of the APFs are they are adaptable to changes in network and load fluctuations and it consumes only less space
compared with the conventional passive filters[H]. Nowadays power quality issues in single phase system is more than three phase
due to the large scale uses of non-linear loads and also due to the increase in newly developed distributed generation systems like
solar photo voltaic, small wind energy systems etc in single phase network [A,G].Reactive power and current harmonics are
significant while considering a single-phase network, which are major concerns for a power distribution system, because these issues
leads to other power quality troubles. In this paper a single-phase shunt active power filter based on indirect control technique for
generating the reference signal is used. In this paper section (2) detailing about single-phase shunt active power filter, section (3) gives
an idea about the indirect control strategy which is then followed by the simulation study and conclusions.
www.ijergs.org
International Journal of Engineering Research and General Science Volume 2, Issue 3, April-May 2014
ISSN 2091-2730
These control strategies are mainly focused on three phase systems [I].The three phase pq theory is made applicable to the
single phase systems by the work of Liu [J] by phase shifting an imaginary variable which is similar to voltage or current signals by 90
degree. Later this concept extended to single phase synchronous d-q reference frame by Zhang [B].
From we can derive fundamental active ,fundamental reactive, harmonic active, and harmonic reactive by using
~
appropriate filters .The DC components
,
are obtained by using LPF and AC components
,
are obtained by using HPF.
278
www.ijergs.org
International Journal of Engineering Research and General Science Volume 2, Issue 3, April-May 2014
ISSN 2091-2730
Here we are using the DC component for the generation of reference current hence it is called indirect method. The load requires only
fundamental active part of the source current.
In order to obtain a constant DC voltage across the active filter the term is added to the above equation.
s
Therefore the reference signal is
The generated reference current is used for making gating pulses to the inverter switches which further inject the compensating current
into the line
4. Simulation Study
The proposed single-phase shunt active power filter using indirect control strategy is simulated in simpower system toolbox in
MATLAB software. Here a 60Hz source is connected to the non-linear diode rectifier load.Due to the non-linearity in the load the
source current is distorted and the THD content is about 38.90%.When the shunt active power filter is connected in between source
and load which injects thenegative harmonic compensating current into the line and the source current regain its sinusoidal nature , the
power factor is much better than without the filter and the THD content is improved to 9.65%.
279
www.ijergs.org
International Journal of Engineering Research and General Science Volume 2, Issue 3, April-May 2014
ISSN 2091-2730
280
www.ijergs.org
International Journal of Engineering Research and General Science Volume 2, Issue 3, April-May 2014
ISSN 2091-2730
281
www.ijergs.org
International Journal of Engineering Research and General Science Volume 2, Issue 3, April-May 2014
ISSN 2091-2730
282
www.ijergs.org
International Journal of Engineering Research and General Science Volume 2, Issue 3, April-May 2014
ISSN 2091-2730
283
www.ijergs.org
International Journal of Engineering Research and General Science Volume 2, Issue 3, April-May 2014
ISSN 2091-2730
5. ACKNOWLEDGEMENT
A colossal number of people have directly or indirectly helped me at different levels of me to successfully accomplish it. It is their
relentless support and care that has got me through this memorable journey of our life. So, here I would like to express our sincere
gratitude towards them.
I am grateful to all faculty members of Electrical Engineering Department, LDRP Institute of Technology & Research. I also thank
our Head of Electrical Engineering Department, Prof. H. N. Prajapati for providing the necessary infrastructure to carry out the paper
work at the institute. Last but not least, we would like to express thanks to the Almighty GOD and our families without whose
blessings the successful accomplishment of this seminar could not have been possible. I will always remember and cherish each and
every one who has helped me to bring the project to this level.
6. Conclusion
A single phase shunt active power filter based on indirect control technique is used in this paper. Using this control strategy
reference signal is generated successfully. The shunt active power filter is found effective in injecting harmonic compensating current
and thereby reducing the source current THD and improves the power factor of the line.The THD is reduced from 38.90% to 9.65%
after compensation. It is also noticed that a constant voltage appears across the DC-link capacitor which helps the smooth functioning
of the voltage source inverter.The shunt active power filter output is verified successfully with the help of MATLAB software.
REFERENCES:
[1]
V Khadikar,A Chandra and B N Singh(2009),Generalised single-phase p-q theory for active power filtering:simulation and
DSP-based experimental investigation, IET Power Electronics,,Vol.2,No.1,pp.67-78.
[2]
R Zhang, M Cardinal, P Szczesny and M Dame(2002), A grid simulator with control of single-phase power converters in
D-Q rotating frame, in proc. IEEE Power Electronics Specialists Conference(PESC),vol.,pp.1431-1436.
[3]
M Gonzalez, V Cardenas and F Pazos (2004),D-Q transformation development for single-phase systems to compensate
harmonic distortion and reactive power, in Proc. IEEE Power Electronics Congress ,pp.177-182.
[4]
S Golestan, M Joorabian, H Rastegar, A Roshan and J.M. Guerrero(2009),Droop based control of parallel-connected single
phase inverters in D-Q rotating frame, in Proc. IEEE Industrial Technology,pp1-6.
[5]
B Singh, K Al-Haddad and A Chandra(1999),A Review of Active Power Filters for Power Quality Improvement, IEEE
Transactions Ind. Electro. Vol 45,no.5,pp.960-971.
[6]
M El-Habrouk,M K.Darwish and P Mehta(2000),Active power filters a review, in Proc. Of IEE-Elect. Power
Appl,vol.147,no-5,pp.403-413.
[7]
Kunjumuhammed L.P,Mishra M.K(2006) ,Comparison of single phase shunt active power filters algorithm, proc. Annu.
Conf..IEEE Power India.
[8]
Mohammad H Rashid(2007),Power Electronics Handbook: Devices Circuits and Applications Elsevier 2e. Single-Phase
Shunt Active Power Filter Using Indirect Control Method 89
[9]
H Akagi, Y Kanazawad and A Nabae (1984),Instantaneous reactive power compensators comprising switching devices
without energy storage Components, IEEE Trans.Ind.Appl,Vol.20.no-3,pp 625-630.
284
www.ijergs.org
International Journal of Engineering Research and General Science Volume 2, Issue 3, April-May 2014
ISSN 2091-2730
[10]
J Liu, J Yang and Z Wang(1999),A new approach for single phase harmonic current detecting and its application in a
hybrid active power filter,inproc.Annu.Conf.IEEE.Indist.Electronics.Soc(IECON99),vol 2,pp,849-854.
[11]
A Vectorial Approach for Generation of Optimal Current References for Multiphase Permanent -Magnet Synchronous
Machines in Real Time Xavier Kestelyn, Member, IEEE, and Eric Semail, Member, IEEE
[12]
A Vectorial Approach for Generation of Optimal Current References for Multiphase Permanent-Magnet Synchronous
Machines in Real Time Xavier Kestelyn, Member, IEEE, and Eric Semail, Member, IEEE
285
www.ijergs.org