Professional Documents
Culture Documents
RD1212 BriefUserGuide en
RD1212 BriefUserGuide en
RD1212 BriefUserGuide en
APPEARANCE
Flashlight
Display
Key
Key
Key
Mini-USB
Battery
compartment lid
Battery compartment
Switching on
Press
Result
The first measurement result will
appear on display after about 10
seconds.
Switching off
Press and hold
DISPLAY LAYOUT
Icons 1- 4, 11, 12 are displayed when the device is turned on.
1. Audible alarm
2. Measuring Cycle in progress
3. Vibration On/Off
4. Backlighting
5. Key function
6. Key function
7. Measurement result
8. Key function
9. Date
10. Time
11. Background Radiation
12. Alarm threshold
- low (battery to be
replaced).
14. Unit of measurement:
micro Sievert per hour
15. Indicates that a quantum was
detected
16. Number of measurement
cycles performed
DEVICE OPERATION
Measurement
Measurements begin when the device is turned on.
Result
MENU
to enter the menu press
use buttons
select
or
to
DATA TRANSFER TO PC
1. You can upload the measured data to PC using RadexRead
software (included on the CD).
2. Connect the device to PC using USB cable (included).
3. Start RadexRead software. Now, the device is ready to sync with PC.
NOTE: Radexread software should be installed on your computer
prior to use.
FLASHLIGHT
To switch the flashlight, press and hold
5
TECHNICAL SPECIFICATION
Range of Indications
Sv/h
MeV
Error,
where dose power in Sv/h
Alarm threshold (increments of 0.05)
Measurement time
Measurement
Batteries ("AAA")
Uninterrupted operation time
Temperature range (humidity should not
exceed 85% at 25C)
Device dimensions
Weight (without batteries)
%
Sv/h
s
0,05 to 999
0,1 to 1,25
0,03 to 3,0
0,4 to 3,5
(15+6/)
pcs
h
0,05 to 1,2
10
permanently
2
300
-18 to +45
mm
kg
97x68x24
0,08
Factory settings
Threshold
Audible alarm
Date collection
Vibrato signal
Backlighting
0,30 Sv/h
on
off
off
off
What is included
RADEX RD1212
CD with software
USB cable
REFERENCE INFORMATION
The sievert (symbol: Sv) is the International System of Units (SI) derived unit of
equivalent radiation dose, effective dose, and committed dose. Quantities that are
measured in sieverts are designed to represent the stochastic biological effects of
ionizing radiation. The sievert should not be used to express the unmodified absorbed
dose of radiation energy, which is a clear physical quantity measured in grays. To
enable consideration of biological effects, further calculations must be performed to
convert absorbed dose into effective dose, the details of which depend on the biological
context. This can be far more complicated than just multiplying by a weighting factor.
The sievert is of fundamental importance in radiation dosimetry, and is named after
Rolf Maximilian Sievert, a Swedish medical physicist renowned for work on radiation
dosage measurement and research into the biological effects of radiation. One sievert
equals 100 rem, an older unit of measurement still in widespread use. One sievert
carries with it a 5.5% chance of eventually developing cancer. Doses greater than
1 sievert received over a short time period are likely to cause radiation poisoning,
possibly leading to death within weeks.
Dose examples
Since radiation doses are not frequently encountered in everyday life, the following
examples can help illustrate relative magnitudes. These are meant to be examples
only, not a comprehensive list of possible radiation doses. An acute dose is one
that occurs over a short and finite period of time, while a chronic dose is a dose that
continues for an extended period of time so that it is better described by a dose rate.
Acute dose examples
98
0.25
5 to 10
80
nSv
Sv
Sv
Sv
Sv