Professional Documents
Culture Documents
Elinor Earrings
Elinor Earrings
SUPPLIES:
15/0 seed beads (SB15)
11/0 seed beads (SB11)
8/0 seed beads - color 1 (SB8A)
8/0 seed beads - color 2 (SB8B)
SuperDuo beads (SD)
Earring wires
2 4mm jump rings
About 1 1/2 yards Nymo B or FireLine
13. Continue on around through the next SB8A, SB11 and the outer
hole of the next SD.
Go through the SB11, SB8A and SB11 in the center.
Go through the outer hole of the next SD then go down through the
next SB11, SB8A and next three SB11.
Skip the next SB11 and go through the next two SB11. Pop out the
bead that you skipped.
14. Weave back around the bottom section of the earring again to
reinforce it. You should go through the next SB11, SB8A, SB11, the
outer hole of the next SD, the SB11, SB8A and the SB11 in the
center. Go on through the outer hole of the next SD, SB11, SB8A
and through all seven SB11 of the bottom point of the earring.
15. Continue on up through the next SB8A, SB11, the outer hole of
the SD, the next SB8B, SB11, three SB15, SB11 and the inner hole
of the SD at the top of the earring.
Go through the outer hole of the same SD.
21. Weave in the working and tail threads and cut them.
22. Attach a jump ring through the SB8B at the top of the earring and attach an
earring wire to the jump ring.