Professional Documents
Culture Documents
Iso 657-1-1989
Iso 657-1-1989
657-l
INTERNATIONAL
STANDARD
First edition
1989-08-01
Hot-rolled
steel sections
Part 1 :
Equal-leg angles -
Profiltk
en acier laminks
l
Dimensions
ii chaud
Dimensions
Reference number
IS0 657-l : 1989 (E)
ISO657=1:1989(E)
Foreword
IS0 (the International Organization for Standardization) is a worldwide federation of
national standards bodies (IS0 member bodies). The work of preparing International
Standards is normally carried out through IS0 technical committees. Each member
body interested in a subject for which a technical committee has been established has
the right to be represented on that committee. International organizations, governmental and non-governmental, in liaison with ISO, also take part in the work. IS0
collaborates closely with the International Electrotechnical Commission (IEC) on all
matters of electrotechnical standardization.
Draft International Standards adopted by the, technical committees are circulated to
the member bodies for approval before their acceptance as International Standards by
the IS0 Council. They are approved in accordance with IS0 procedures requiring at
least 75 % approval by the member bodies voting.
International Standard IS0 657-l was prepared by Technical Committee
S tee/.
ISO/TC 17,
It cancels and replaces IS0 Recommen dation R 657-l : 1968, of which it constitutes a
technical revision.
IS0 657 consists of the following
steel
sections :
-
Part 7: Equal-leg
angles -
Fart 2: Unequal-leg
Part 5: Equal-leg
inch series
Dimensions
angles -
Dimensions
Part 7 7 : Sloping
sectional properties
flange
channel
on sloping
(metric
-
series) -
Dimensions
flange beam,
series)
column
Part 2 7 : T-sections
sections
Dimensions
and
sections
Dimensions
and sec-
and sec-
(metric
and channel
flats (metric
Tolerances
Tolerances
angles -
series) -
Dimensions,
Dimensions,
sectional
set tional
properties
and
Dimensions
Dimensions
0 IS0 1989
All rights reserved. No part of this publication may be reproduced or utilized in any form or by any
means, electronic or mechanical, including photocopying and microfilm, without permission in
writing from the publisher.
International Organization for Standardization
Case postale 56 l CH-1211 Geneve 20 l Switzerland
Printed in Switzerland
INTERNATIONAL
STANDARD
Hot-rolled
steel sections
Part 1:
Equal-leg angles -
Dimensions
Scope
3.1
3.2
2
Normative
reference
angles
- Part 5 : Equal-leg
Tolerances for metric and
Dimensions
only.
3.3 The toe radius has not been specified and may, if considered necessary, be determined independently for national
standards.
Sectional
properties
Dimensional
tolerances