Professional Documents
Culture Documents
(Current) MM1130 - InteliJet HD User Manual.21-29
(Current) MM1130 - InteliJet HD User Manual.21-29
(Current) MM1130 - InteliJet HD User Manual.21-29
Start-Up Procedure
This Procedure is required to be performed before operating the printer after a Machine Shut-Down
procedure has been completed.
Procedure:
Turn on Main Power switch
Turn on Computer Switch
Turn on Computer switch located behind the right door on the Computer
Turn on HD System Switch
Turn on UV1 switch
Load Print Server
Load Layout Client
Load Bell-Mark IJHD Interface
Remove Guard
Page 15
Lower the IJHD Platen by releasing the locking handle and turning the crank handle
Counter Clock Wise.
Pull out the IJHD Head Module by releasing the Locking pin and gently pulling on the
handle.
Page 16
CAREFULLY - Place the Drip Tray onto the bottom of the HD Head Module and turn the
tabs inward to allow the tray to hang from the head module
Page 17
Gently wipe print heads in the directions shown below, using only approved lint-free
wipes available from Bell-Mark (P11233)
Note: After wiping, the print heads should remain damp yet free of any visible droplets
that may drop off of the print heads.
CAREFULLY - Remove the Drip Tray from the bottom of the HD Head Module
Page 18
Close side access door and push the HD head module back in until the locking pin
snaps into place.
Lift the IJHD Platen by releasing the locking handle and turning the crank handle Clock
Wise until the handle locks into the upper most position.
Replace Guard
Page 19
Shut-Down Procedure
This Procedure is required to be performed before allowing the machine to set idle for
longer than 2 hours.
End any active Print Job by clicking on the red stop button in the Layout software.
Remove Guard
Lower the IJHD Platen by releasing the locking handle and turning the crank handle
Counter Clock Wise.
Page 20
Pull out the IJHD Head Module by releasing the Locking pin and gently pulling on the
handle.
Place the Capping Plate Under the HD Head Module, Making sure that the locking feet
have fallen into their locating cutouts
If open, close side access door and push the HD head module back in until the locking
pin snaps into place.
Page 21
Lift the IJHD Platen by releasing the locking handle and turning the crank handle Clock
Wise until the handle locks into the Middle position.
Page 22
Release Ink bottle door by un-latching the clip at the top of the door.
Lower door and Remove the Ink bottle by rotating slightly and lifting up and out.
Page 23