Professional Documents
Culture Documents
Resume of Rrobinsonl
Resume of Rrobinsonl
Calibration Metrology Tester: Calibrate, repair and certify process control instrument to
National Institute of Standards Technology using instrument test standards and test instruments,
such as Wallace & Tiernan Pneumatic Comparator, Analogic Digi-Cal Calibrator, Transmation
Milliamp Millivolt Tester, Digital Volt OHM Meter, Tektronix Oscilloscope, Dwyer Manometer,
Wet-Bulb Thermometers, Bulb Respirators, etc.
Troubleshoot and repair (20) Oil Rigs over Northern California, PLC and controllers (4)
types Honeywell, Hart, Foxboro and Yocogowa Removing instruments from service
without slowing operation. Revise / Draw loop sheet as necessary and calibrate, design /
improve control configuration, Loop Turning, Perform the needed. DCS configuration
changes. Maintain the Foxboro I/A control system. Perform special I/ E tuning. Overtime
and call out coverage for the District of Northern California as required, read PID spec for
Insp I also work with Detroit Diesel Engine, Allison Transmission Electronic. Voltage was
from 600,480,220,110 and motor size was from 50 to 60 power and 3 amp breaker.
Inspecting, installing, calibrating, repairing, maintaining and troubleshooting electrical,
mechanical and other instruments and control equipment. Ordering parts and supplies
and maintaining a spare parts inventory, preparing reports and keeping a record of work
performed.
Supervisor: Paul Boulet, Principal Engineer (Electrical) Supervisor (713) 560-4515
EDUCATION:
College of Instrument Technology, Bellflower, CA
Bachelors’ Degree in Science of Instrumentation
& Process Control Engineering
Calibration Metrology Tester, July 2004
California State University of Sacramento, Sacramento, CA
Waste Water Grade I and II
CERTIFICATIONS:
Diplomas in Basic Instrumentation
Calibration Metrology Tester
Advanced Instrumentation Electronics Stewart & Stevenson Freightliner Detroit
Diesel (DDEC IV/V OFF-HIGHWAY in Electronics)
Allison Transmission CEC II
National Oil well Varco5C KECS Work over Rig Operation and Maintenance
Training.
Womack Hands-On Hydraulic Training and Troubleshooting
Premier Guard Co2 Analytical System
Wastewater Treatment Plant Vol I and II
Analyzers and Electronic Instruments
40-Hours Hazwoper (OSHA 29 CFR 1910.120)
8-Hours Confined Space, Competent Person & Supervisor
MILITARY SERVICE:
U.S. Army Ranger Special Forces, Honorable Discharged May 14, 1985
PROFESSIONAL MEMBERSHIPS:
ISA The Instrumentation Systems and Automation Society Member No.32908493