Professional Documents
Culture Documents
Open and Closed Fracture
Open and Closed Fracture
FRACTURES
Cracks that occur in bone, most often seem in tibia or fibula or metatarsal especially in
dancers, athletes and army recruits.
3.
Pathological fracture
Fractures that occur in bone that has been weakened (by tumour or excessively brittle as
in Pagets disease.
Types of incomplete fractures ( bone incompletely divided & periosteum remains in continuity)
Greenstick
Compression fracture
Classification
Open ( Compound ) Fracture- Disruption of overlying skin. Fracture site is in direct
contact with environment, therefore liable to contamination and infection.
GUSTILOS CLASSIFICATION
(open fracture)
TYPE
SIZE (CM)
<1
Low energy
Small wound, clean puncture
Little soft tissue damage, no crushing
II
<10
Moderate energy
No skin flap
Not much soft tissue damage, no more than moderate
crushing or comminution of fracture
III
>10
A
B
C
Antibiotic prophylaxis
Urgent wound and fracture debridement
Stabilization of fracture
Early definitive wound cover
Aim
Method
Reduce
-manipulation
-mechanical traction
-open reduction
Hold
-sustained traction
-cast splintage
-functional bracing
-internal fixation
-external fixation
Exercise
Reduction
Hold
1. Continuous traction
Traction by gravity- applies only to upper limb injuries. By the wrist sling,
weight of the arm provides continuous traction to the humerus
Skin traction- sustain a pull no more than 5 kg
Skeletal traction- by using wires or pin inserted usually at behind tibial
tubercle for hip, thigh abd knee injuries, lower in tibia or calcaneum for tibial
fractures.
Traction must be opposed by counter-traction
Fixed traction Pull is exerted againts a fixed point eg; tapes are tied to the cross piece
of Thomas splint and pull the leg down
Balanced traction Pull is exerted againts an opposing force provided by the weight of
the body when foot of the bed is raised. The cords may be tied to the foot end of the
bed, run over pulleys or have weights attached.
Traction
(a)
(d)
23.14 M ethods of
traction (a) Traction by
gravity. (b,c,d) Skin traction:
(b) xed; (c) balanced;
(d) Russell. (e) Skeletal
traction with a splint and a
knee-exion piece.
(b)
(c)
(e)
2. Cast splintage
Achieved by using Plaster of Paris
History : 1850s first used during Crimean war (by Dutch army doctor)
Why Paris?
Gypsum plaster, or plaster of Paris, is produced by heating gypsum to about 150 C
2CaSO44H2O + Heat 2CaSO4H2O + 3H2O (released as steam).
Reabsorb water rapidly forming hydrate calcium sulphate and release heat (exothermic reaction)
2 (CaSO4 H2O) + 3 H2O 2 (CaSO4.2H2O) + Heat
Advantages
Cost-effective
Easily molded
Non-allergic
Disadvantages
Non-radiopaque
Heavy
Easily breaks
Advices
Keep dry, clean
Dont put long object inside or scratch
Elevate cast to reduce swelling
Come to hospital ASAP if
Pain, numbness, swelling, bluish discoloration
Complications;
Tight Cast
oPt complained of diffused pain-> signs of vascular compression
Elevate the limb. If doesnt subside during next hour, SPLIT the cast
throughout it length
If swelling anticipated, cast should be apply over thick padding then split
before it set
Pressure sores (esp over bony prominence)
Prevented by padding all bony prominence before casting
Skin Abrasion (during removal)
Loose Cast
Replaced the cast
3. Functional bracing
-segments of a cast only applied over the shafts of the bones,leaving the joint free (eg in fracture of
femur / tibia)
-usually applied when the fracture is beginning to unite (ie> 3-6 wks)
4. Internal fixation
Types (screws, wires, plates and screws, intramedullary nails)
5. External fixation
Bone is transfixed above and below the fracture with screw/wire then clamped to frame or rigid bars
COMPLICATION OF FRACTURE
EARLY COMPLICATION
1)
2)
3)
4)
5)
6)
7)
8)
Compartment syndrome
Fat embolism
Visceral injury
Vascular injury
Nerve injury
Haemarthrosis
Infection
Gas gangrene
LATE COMPLICATION
1.
delayed union
2.
non-union
3.
malunion
4.
avascular necrosis
5.
growth disturbance
6.
nerve compression
7.
muscle contracture
8.
joint instability
9.
joint stiffness
Compartment syndrome
Bleeding, oedema or inflammation increase the pressure
within one of the osseofascial compartment -> reduced
capillary flow -> muscle ischaemia -> further oedema
A viscious circle
More to high risk injury-elbow,tibia,forearm bones
features of ischaemia (5 Ps)
Pain(bursting sensation)
Paraesthesia
Pallor
Pulselessness
Paralysis
Mx:
FAT EMBOLISME
Occur in most adults after closed fracture of long bones.
Fat globules can circulate in lungs and other internal
organ
Features (similar to ARDS):
MX:
Supportive
Use of supplemental high inspired O2 concentrations to
reduced symptoms.
Fixation of fractures.