For certain aspects of design it is necessary to obtain the tensile strength of concrete. The document summarizes two tests for measuring the tensile strength of concrete: the modulus of rupture test which uses a small beam to determine tensile strength, and the cylinder-splitting test which applies a concentrated load to a cylinder. Both tests are used to determine the direct tensile strength of concrete, with the modulus of rupture varying between 11-23% of the compressive strength.
For certain aspects of design it is necessary to obtain the tensile strength of concrete. The document summarizes two tests for measuring the tensile strength of concrete: the modulus of rupture test which uses a small beam to determine tensile strength, and the cylinder-splitting test which applies a concentrated load to a cylinder. Both tests are used to determine the direct tensile strength of concrete, with the modulus of rupture varying between 11-23% of the compressive strength.
For certain aspects of design it is necessary to obtain the tensile strength of concrete. The document summarizes two tests for measuring the tensile strength of concrete: the modulus of rupture test which uses a small beam to determine tensile strength, and the cylinder-splitting test which applies a concentrated load to a cylinder. Both tests are used to determine the direct tensile strength of concrete, with the modulus of rupture varying between 11-23% of the compressive strength.
For certain aspects of design it is necessary to obtain the measure tensile
strength of concrete. the modulus of rupture test, and the direct tensile, or cylinder-splitting test is a test for concrete measured. The modulus of rupture test is carried out on a standard small beam and length 700 mm. The flexural formula is used to determine the extreme fibre tensile. The modulus of rupture varies between 11% and 23% of the compressive strength. The cylinder-splitting test a concentrated line applied to the cylindrical specimen laid on edge, equilibrium of internal forces, compressive stresses must exist at the top and bottom cylinder. The direct tensile strength of the concrete varies. The direct tensile tensile strength determined in this way. The test may also be used to determine the compressive strength of a specimen.