Professional Documents
Culture Documents
SIIG Wifi Extender
SIIG Wifi Extender
Extender
Quick Installation Guide
Introduction
The Wireless-N Wi-Fi Repeater/Extender can extend
and increase signal strength for 802.11n/g/b
wireless networks.
System Requirements
04-0867A
Package Contents
Layout
Power
LED
Wireless indicator
LED
Ethernet indicator
LED
RJ-45 Port
Reset button
Figure 1: Layout
Figure 2
4.
192.168.10.1
admin
OK
Figure 3
5.
Wireless Repeater
Mode
Next
Figure 4
4
2.
3.
Click radio
button to select
Figure 5
4.
Pre-shared key
Figure 6
5.
Repeater
Connected
Figure 7
6.
AP Mode Configuration
This mode gives a non-wireless connection
wireless-N capabilities.
1.
In the main menu, click Setup Wizard on
the left side bar, select Standard Wireless
AP Mode, click Next.
2.
Click AP - OneKey Setting.
3.
The Repeater/Extender will be configured
automatically to the AP mode. see Figure 8.
6
AP
4.
Figure 8
WPA2
Apply
Changes
Figure 9
5.
Apply Changes
Figure 10
8
Wireless - WPS
1.
2.
Start PBC
Figure 11
Application
PC
PC
Internet
Router
PC
PC
Ethernet
cable
Internet
PC
Router
Figure 13 AP Mode
10
Properly pack the product for shipping. All accessories that came with the
original package must be included.
Clearly write your RMA number on the top of the returned package. SIIG will
refuse to accept any shipping package, and will not be responsible for a product
returned without an RMA number posted on the outside of the shipping
carton.
You are responsible for the cost of shipping to SIIG. Ship the product to the
following address:
SIIG, Inc.
6078 Stewart Avenue
Fremont, CA 94538-3152, USA
RMA #:
SIIG will ship the repaired or replaced product via Ground in the U.S. and
International Economy outside of the U.S. at no cost to the customer.
11
Wireless-N Wi-Fi Repeater/Extender is a trademark of SIIG, Inc. SIIG and the SIIG logo are
registered trademarks of SIIG, Inc. All other names used in this publication are for identification
only and may be trademarks of their respective owners.
April, 2013