Professional Documents
Culture Documents
Load Evaluation PDF
Load Evaluation PDF
Load Evaluation
1.1 Dead load
Self-weight of the structure is taken into account by SAP program when performing the structural
analysis. Calculation of the dead load of structural elements is no needed.
Dead load from roof system. Following elements are used for roof system:
Purlins Z150/1.5, placed at 1 m distance :
Gpurlin 3.06
Gpurlin
=> gpurlin
9.81 = 0.03
2
2
1.00
groof.coverings 0.44
1.1 = 0.484 (1.1 - coeficient for other elements)
2
2
gk.roof gpurlin + groof.coverings = 0.514
2
Dead load from the slab.
gk.slab 6.76
2
1.2 Live loads SR EN 1991-1-1/NA-2006
The building is composed of 2 bodies: office building and industrial hall.
For categories of use:
- office building: category B - office areas
-industrial hall: category E2 - industrial use
Office building live loads:
-for floors:
qk.floor 2.5
2
-for partitions walls: self weight<3.0 kN/m =>
qk.partition 1.2
2
The roof is considered not accesible except for normal maintenance and repair, being in category H.
qk.roof 0.75
2
13S
d CR 1 1 3/2012
Ce 1.0
Computation of qp ze
qp.z cpq.z qm.z
cpq.z 1 + 7 Iv.z
z0 0.05
2
z0 0.05
zmin 2
b 2.66
> zmin
z 8.9
2.66
Iv.z = 0.205
z
2.5 ln
z0
cpq.z 1 + 7 Iv.z = 2.437
2
qm.z cr.z qb
The building is located in Timisoara.
qb 0.6
2
kr.z0 0.189
z 8.9
> zmin
z
cr.z kr.z0 ln = 0.979
z0
2
For roof:
Slope of the roof is: 5.71
a) Wind direction: q=0
e min (b , 2 h)
b 36
h = 8.9
e min (b , 2 h) = 17.8
For walls:
a) Wind direction: q=0
e min (b , 2 h)
b 36
h = 8.9
e min (b , 2 h) = 17.8
d 18
e<d
h
= 0.494
d
Wind pressures:
ag 0.2
TC 0.7
= 1.961
2
TB 0.14
TD 3
TC
0.7
TB
0.14
TD
0 2.5
0v 1
v (T) 1 +
T
TBv
v (T) 0v
TCv
v (T) 0v
T
v (T)
0v
T
TCv TDv
v (T) 0v
2
T
0v 2.75
The vertical component of the seismic action will not be considered for this building. The building do not
have a great hight, so there is no important influence of the vertical component.
Destination of the building is industrial hall: Class III => I.e 1.0
The behaviour factor for the office building:
- for baced frames : q=6.5
-for non-braced frames : q=4
The structure will be design for DCH class.
The behaviour factor for the industrial hall: q=1.5
The structure will be design for DCL class.