Professional Documents
Culture Documents
Storch Flight Manual - Eng Version 28 - 04 - 05 PDF
Storch Flight Manual - Eng Version 28 - 04 - 05 PDF
FLIGHT MANUAL
(VALID FOR JABIRU 2200 ENGINE VERSION)
00
01
Num.
28/04/05
21/04/05
Date
Modified Section 5
Updated manual
Description
REVISION
M. Fiorindo
M. Fiorindo
R. Ciotti
R. Ciotti
R. Ciotti
R. Ciotti
Preparation
Verification
Approval
FlySynthesis s.r.l. reserves it to terms of law the exclusive ownership of this manual and also forbids the partial reproduction of it.
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
2 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
LOG OF REVISIONS
All the revisions to this Flight Manual MUST BE recorded in the following TABLE:
Revision Number
Revision
Date
Signature
01
Apr/05
M. Fiorindo
Apr/05
M. Fiorindo
02
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
3 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
Data
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
Pagina
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
Data
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
April 2005
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
4 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
PURPOSE
This manual contains the necessary information for a sure and efficient employment of the aircraft
FLYSYNTHESIS STORCH HS JABIRU 2200.
The observance of this manual is obligatory for the aircraft's use.
FLYSYNTHESIS S.r.l. declines every responsibility for any damage to person and thing derived
by a missed or partial observance of the prescriptions contained in this manual.
FLYSYNTHESIS S.r.l. reserves it, to terms of law, the exclusive ownership of this manual and
also forbids the partial or integral reproduction of it and however to communicate it to competing
firms without a preventive written authorization.
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
5 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
INDEX
Section
Title
Page
Introduction
Limitations
11
Normal procedures
21
Emergency procedures
32
Performances
38
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
6 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
SECTION 1
Introduction
INDEX
Title
Page
- Dimensions
- Meteorological terminology
10
- Powerplant terminology
10
10
- Miscellaneous
10
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
7 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
8 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
DIMENSIONS
General
Wing span:
Length:
Height:
8.71 m
5.75 m
2.45 m
Wing
Surface:
Wing chord:
Wing loading:
11.67 m2
1.34 m
40.5 kg/m2
Ailerons
Surface:
Span:
Chord:
Travel:
1.08 m2
3.36 m
0.25 m
+15 -2
Stabilator
Surface:
Span:
Chord:
Travel:
1.65 m2
2.45 m
0.7 m
+17 -12
1.12 m2
1.28 m
0.93 m
Directional rudder
Surface:
Height:
Mean chord:
Travel:
0.6 m2
1.20 m
0.48 m
+/-22
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
9 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
CAS
Calibrated Airspeed, indicated airspeed correct for position and instrument error.
CAS is equal to TAS in standard atmosphere at sea level.
IAS
TAS
True Airspeed is the airspeed relative to undisturbed air that is CAS correct for
altitude, temperature and compressibility.
Vfe
Maximum Flap Extended Speed is the highest speed permissible with wing flaps in a
prescribed extended position.
Vne
Speed Never Exceed is the speed limit that must never be exceeded.
Vmo
Maximum Structural Cruising Speed is the speed that never must be exceeded in
turbulent air.
Va
Vx
Best angle-of-climb speed is the speed that results in the greatest gain of altitude in a
given horizontal distance.
Vy
Best rate-of-climb speed is the speed that results in the greatest gain of altitude in a
given time.
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
10 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
METEOROLOGICAL TERMINOLOGY
OAT
Outside Air Temperature is the free air static temperature. It is expressed in either
degrees Celsius or degrees Fahrenheit.
ISA
2.
3.
4.
The temperature gradient from sea level to the altitude at which the temperature is 56,5 C (-69,7 F), is -1,98 C (-3,6 F) per 1000 feet.
POWERPLANT TERMINOLOGY
Throttle Lever
Carburettor Heat Control
Tachometer
Cylinder Head Temperature
Choke
Rate of climb
Demonstrated Crosswind
Land immediately
MISCELLANEOUS
M.A.C.
C.G.
Centre of gravity.
Rh
Lh
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
11 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
SEZIONE 2
Limitations
INDEX
Title
Page
- Generality
- Airspeed limitations
- Powerplant limitations
- Fuel quantity, oil type and atmosphere temperature
- Weight limitations
- Center of gravity limitations
- Determination of empty weight and C.G.
- Weighing procedure
- Manoeuvre limitations
- Load factor limitations
- Minimum flight crew
- Configuration with the maximum passengers seating
- Kind of operations
- Instruments markings
- Placards
12
12
12
13
13
14
15
15
18
18
18
18
18
19
20
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
12 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
GENERAL
This section includes operating limitations, instrument markings necessary for the safe operation of
the aircraft, of the engine and its standard systems and equipments. All speed limitations are taken
following the LTF-UL rules.
AIRSPEED LIMITATION
- Never Exceed speed (Vne)
- Maximum Structural Cruising Speed (Vmo)
- Manoeuvring speed (Va)
- Maximum speed with full flaps (Vfe)
- Best angle of climb speed Vx
- Best rate of climb speed Vy
- Stall speed (Vs1 )
- Stall speed with full flap (Vs0 )
205 Km/h
173 Km/h
127 Km/h
105 Km/h
110 Km/h
90 Km/h
64 Km/h
58 Km/h
POWERPLANT LIMITATIONS
(Ref. JABIRU 2200 operator's manual)
Following limitations apply:
- Maximum engine take off power
85 HP
3.300 RPM
200 C
175 C
118 C
Fuel:
For information detailed on the approved fuels to refer to the edition attached of the" JABIRU
operator's manual."
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
13 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
2 x 30 L.
2 L.
58 L.
ENGINE OIL
For detailed information on recommended oil grades refer to the attached edition of JABIRU
operator's manual.
ATMOSPHERIC TEMPERATURE
Maximum atmospheric temperature at which the aircraft has been verified as functional (determined
by tests) is 37.8 C (100 F).
WEIGHT LIMITATIONS
Empty weight
Kg s 270
Kg s 70
Kg s 100
Kg s 170
Kg s 46.5
Kg s 12
Kg s 450
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
14 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
15 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
WEIGHING PROCEDURE
For the weighing of the aircraft, must be respect the followings conditions:
The equipments must be those foreseen by the list related to the aircraft in question.
Must be included the liquid brakes, the oil motor, the liquid antifreeze and the non usable
fuel.
Must be necessary the use of a balance to three independent sensors and sets on the same horizontal
plan and of a thread to lead.
To determinate the empty weight and the position of the Center of Gravity, the aircraft must be
positioned on three autonomous balances, one for wheel. It is fundamental that the longitudinal and
lateral axis of the aircraft are both in horizontal position.
Using the thread to lead, must be determinate the projection to the ground of the plan of reference
RD. From this plan all the necessary measures to the correct application of the computational
formula are brought.
All data must be transcribed on the "Weighing Report", as from the form - A.
CENTRE GRAVITY POSITION REPORT
The first recording of the Weighing Report & the Centre Gravity Position of the aircraft, is effected
in factory before the delivery of the same aircraft.
Every variation due to the installation of new components or reparation or painting, implicate a new
calculation of the empty weight and the relative positioning of the center of gravity.
All data must be transcribed on the "Centre Gravity Position Report", as from the form - B.
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
16 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
Rapporto di pesata
Weight & balance report
MODULO A: Pesata a vuoto
Sheet model A: Empty weight
Identificazione/ Identification:
Pagina/Page:
Data/Date:
Preparazione/Preparation:
Verifica/Verify:
Approvazione/Approvation:
RP 001 Rev 00
0/2
02/lug/2005
M. Fiorindo
M. Garofolo
R. Ciotti
Bilancia (balance)
Frontale / Frontal (P 1)
Posteriore sx / LH Rear (P2 S)
Posteriore dx / RH Rear (P 2D)
Massa totale (Total weight)
Posizione del CG (CG Position):
Momento della Massa (Weight Moment):
ML = Kgm
Posizione del baricentro (CG Position):
XT = m
XT% = (XT / MAC) x 100
XT% = %
Peso Lordo
(Gross weight)
kg
Tara
(Tare weight)
kg
-
PT = kg.
M L = P 2 x X 2 P 1 x X1
M L = P T x X T ? X T = ML / PT
A
B
A-B
kg.
kg.
kg.
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
17 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
Rapporto di pesata
Weight & balance report
MODULO B: Cambiamenti di massa
Sheet model B: Weight changes
Modello/Model:
Data/Date:
N Serie/Serial number:
Identificazione/ Identification:
Pagina/Page:
Data/Date:
Preparazione/Preparation:
Verifica/Verify: :
Approvazione/Approvation:
RP 002 Rev 00
0/1
27 /09/2005
M. Fiorindo
M. Fiorindo
R. Ciotti
Registrazione/Registration:
Pagina/Page:
Massa a vuoto attuale /Actual
empty weight:
Massa Braccio
Weigh Arm
t[Kg] [m]
Momento
Moment
[Kgm]
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
18 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
MANOEUVRE LIMITATIONS
All aerobatics maneuvers are prohibited.
WARNING
a.
All maneuvers at load factor less than - 0.5 g, must be performed for no longer than 5
seconds
b.
In single pilot operation, belt and shoulder harness of the vacant seat must be secured to
avoid uncontrolled movement of seat back and belt.
Maximum positive 4
Maximum negative 2
KINDS of OPERATIONS
The aircraft must operate only during visual flight rules.
Flight operations of the aircraft have to comply with the applicable national flight operation
regulations.
WARNING
Flight in known icing conditions, snow and heavy rain is prohibited.
The pilot is responsible for determining the airworthiness of the aircraft for each flight including on
board fuel lever verification.
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
19 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
INSTRUMENTS MARKING
AIRSPEED INDICATOR (IAS)
- White arc
From
58 Km/h
to
105 Km/h
- Green arc
From
64 Km/h
to
173 Km/h
- Yellow arc
From
173 Km/h
to
195 Km/h
- Red line
195 Km/h
TACHOMETER (RPM)
- Green arc
From
900 RPM
to
3.000 RPM
- Yellow arc
From
3.000 RPM
to
3.300 RPM
- Red line
3.300 RPM
0,05
From
0,05
- Red line
to
0,2
0,2
0,8
- Yellow arc
From
0,8
to
2,2
- Green arc
From
2,2
to
5,25
- Red line
5.25
15
- Yellow arc
From
15
to
80
- Green arc
From
80
to
100
- Yellow arc
From
100
to
118
- Red line
118
50
- Green arc
From
50
to
175
- Yellow arc
From
175
to
200
- Red line
200
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
20 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
PLACARDS
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
21 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
SECTION 3
Normal procedures
INDEX
Title
Page
22
Flight Preparation
23
Pre-flight Inspection
29
29
Engine start
29
Before taxing
29
Taxing
29
Engine checks
30
Before take-off
30
Take-off
30
Climb
31
Cruise
31
Descent
31
Landing
31
Touch and go
31
After landing
32
Engine shutdown
32
32
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
22 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
Km/h
75
Km/h
80
Km/h
90
Km/h 110
CLIMB, Flaps UP
MANOEUVERING SPEED
Manoeuvring speed (Va)
Km/h 127
Km/h 183
Km/h 205
km/h
110
Landing
km/h
90
Touchdown
km/h
80
km/h
85
Km/h
28
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
23 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
FLIGHT PREPARATION
OPERATING LIMITATIONS
Refer to Section 2.
FLIGHT PLANNING
Data required for flight planning is contained in section 5.
WEIGHT and BALANCE
Refer to section 5 for weight and balance limitations
NOTE: Complete all the operations described following with the MASTER KEY OFF ,
DRAIN FUEL
Open the faucet situated in the LH inferior fusolage side, near the principal landing gear structure.
Use a transparent and clean container.
For a correct drain fuel is sufficient scour about 80/100 cc.
Prudence
Is necessary to perform this operation before moving the airplane from the parking for avoid that
the condenses water present on the fuel tank fund is emulsified with the fuel.
Check water presence. Repeat the operation one or more times.
REFUELING
Warning: use only fuel specified in Jabirus operator manual.
Refueling procedure is performed through electric pump commanded from cockpit.
REFUELING OPERATIONS
1) Verify that the pipelines fuel are connected with safety; use the special refueling filtered pipeline
(check refueling filtered pipeline integrity and cleaning)
2) Join the refueling filtered pipeline with refueling faucet in the RH inferior fusolage side, near the
principal landing gear structure. Put the other extremity of refueling filtered pipeline in the external
fuel tank.
3) Start the fuel loading pump and open the refueling faucet.
4) When the refueling procedure is complete,
operation for both tanks.
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
24 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
PRE-FLIGHT INSPECTION
WARNING
Before every flight pilot must check completely the airplane with great attention and accuracy.
In this section there is a standard pre-flight check list.
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
25 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
BLOCK
ENTIRE CLEANING BETWEEN WHEEL & FAIRING
ENTIRE SUITABLE PRESSURE
ABSENCE OF DEFORMATIONS
NUTS BLOCK; ABSENCE OF DEFORMATIONS
WITH RUDDER & WITH RUDDER PEDALS IN NEUTRAL
POSITION
ENTIRE - CLEAN
BLOCK
ENTIRE
FIXING ENTIRE
RIVETS LOCKED
NUTS LOCKED
d) PITOT TUBE
ENTIRE
LINED UP WITH FUSELAGE AXLE
ABSENCE OF OBSTRUCTIONS
PLASTICS PIPE CORRECTLY CONNECTED
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
26 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
BLOCK
ENTIRE & WITHOUT HARD BENDING
ABSENCE OF LOSSES OF OIL CORRECT PINCER/DISC
FIXING
c) TIRE
ENTIRE
CORRECT TIRE PRESSURE
d) WHEEL FAIRING
ENTIRE
FIXED
CLEANED BY MUD, GRASS ETC.
VII FUSOLAGE: CENTRAL SIDE
a) FUSOLAGE BEAM
Fixing rivets:
Bowden cables:
FIXED
FIXED
FIXED
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
27 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
ENTIRE
PRESENTS, ABSENCE OF LOOSENING
ENTIRE
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
28 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
FIXED
USEFUL FRICTION (FOR EACH LEVER)
VERIFY SMOOTHNESS OF MOVEMENT & THE SMOOTHNESS OF RETURN OF CABLES
ABSENCE OF CABLES FRAY, USURY & BENDING
e) WING STRUT JUNCTION
ABSENCE OF CRACKS
PINS & NUTS SECURITY JOINTS
f) SAFETY BELTS
ENTIRE
SECURITY OF JOINT
g) DOORS
ABSENCE OF CRACKS CORRECT CLOSING
h) SEATS
ENTIRE CORRECT FIXING ABSENCE OF CRACKS
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
29 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
External check
Seat
Seat belts
Doors
Parking brake
Control sticks
Fuel switch
Trim
- PERFORMED
- WELL ADJUSTED
- FASTEN AND WELL ADJUSTED
- CLOSED AND LOCKED
- ON
- FREE MOVEMENT
- OPEN RH, CLOSE LH
- NEUTRAL POSITION
ENGINE START
o Choke lever:
o Electrical pump
o Fuel throttle:
Cold engine
Warm up
Cold engine
Warm up
o Master Key
o Ignition magneto
o Generator lamp
- ON (REARWARD POSITION),
- OFF (FORWARD POSITION)
- ON FOR 5 SEC. - THEN OFF
- AT MINIMUM,
- FORWARD 1 CM,
- ON
- Both ON
- ON
ATTENTION: ENSURE THAT PROPELLER AREA IS CLEAR OF ANY PERSON AND OBJECT
o
o
o
o
BEFORE TAXIING
o
o
o
o
o
Electrical system
Navigation instrument
Flaps
Altimeter
Parking brakes
- ON AND CHECKED,
- CHECKED,
- TAKE OFF POSITION, 15
- ADJUST AS REQUIRED,
- OFF,
TAXIING
s)
t)
u)
v)
Brakes
Control surface
Flight instruments
Throttle
- CHECK EACH,
- CHECK SMOOTHNESS (STICK AND PEDALS),
- CHECK,
- HOLD MODERATE,
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
30 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
ENGINE CHECKS
o
o
o
o
o
o
o
o
Parking brakes
Fuel switch
Pressure & temperature
Trim
Flight control
Check magnetos at 2000 RPM
Throttle
Check minimum RPM
- ON
- OPEN LH, CLOSE RH
- INSIDE GREEN ARC
- NEUTRAL POSITION
- FREE, SMOOTHNESS OF MOVEMENT
- MAXIMUM DROP. 50 RPM FOR EACH
- VERIFY MIN. 2800 RPM +/- 150 FOR 5 SEC.
- 900 RPM
- ON
- OPEN LH OR RH
- INSIDE GREEN ARC
- CHECK & REGULATE
- SAFETY LOCKED
- CLOSED & LOCKED
- OFF
TAKE OFF
o
o
o
o
Aircraft
Throttle
At 75 km/h
Climb velocity
- RUNWAY ALIGMENT
- MINIMUM 2800 RPM
- ROTATION
- Vx OR Vy
- UP
- AS NECESSARY
- AS NECESSARY
- OFF
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
31 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
CLIMB
o
o
o
Engine
Engine instruments
Trim
- 3300 RPM.
- INSIDE GREEN ARC
- AS NECESSARY
CRUISE
o
o
o
Throttle
Engine
Engine instruments
- AS NECESSARY
- NOT FURTHER MAXIMUM CONTINUOS 3300 RPM
- INSIDE GREEN ARC
ATTENTION:
Frequently check fuel levels, reservoirs selection and engine parameters inside green arc.
DESCENT
o
o
o
o
o
Altimeter
Warm air to carburettors
Throttle
Trim
Engine instruments
LANDING
o
o
o
o
o
o
o
o
Approaching speed
Flap
Trim
Throttle
Fuel electric pump
Check hydraulic brakes (see b note)
Landing approach speed
Landing speed
- 105 km/h
- AS NECESSARY
- AS NECESSARY
- AS NECESSARY
- ON
- CHECK (if installed)
- 90 km/h
- 70 km/h
NOTE:
a) For hard wind conditions, gusts or crosswind, increase the approaching speed than at least 10
km/h & landing speed than at least 5 Km/h.
b) Hydraulic brakes test: pull brakes lever to maximum extension, one or twice time, & verify the
correct functionality (for normal conditions, a certain brake lever resistance must be noticed).
TOUCH & GO
o
o
o
o
Throttle
Trim
Flap
Climb velocity
- TO FULL POWER
- AS NECESSARY
- 15
- Vx o Vy
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
32 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
AFTER LANDING
o
o
o
o
o
Throttle
Flaps
Taxiing
Electric fuel pump
Brakes
- AT MINIMUM
- UP
- FREE A.S.A.P. THE RUNWAY
- OFF
- CHECK WARM BRAKES FUNCTIONALITY
ENGINE SHUTDOWN
o
o
o
o
Parking brake
Electric plant
Magnetos
Master
- ON
- OFF
- OFF (ONE BY ONE)
- OFF
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
33 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
SECTION 4
Emergency Procedures
INDEX
Title
Page
34
34
35
36
37
38
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
34 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
- CLOSED
- OFF
- ON
- AT MAXIMUM
- OFF
- OFF
- OFF
- AT MINIMUM
- AS NECESSARY
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
35 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
- CLOSED
- AT MAXIMUM
- OFF
- OFF
- 110 Km/h
NOTE: Don't try to a start up engine procedure after an engine fire. Landing ASAP.
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
36 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
Electrical equipment
Ventilation
Master key
Land ASAP
- OFF
- OPEN
- OFF
SMOKE ELIMINATION
1. Ventilation
- OPEN
2. Master key
- OFF
3. If smoke doesnt reduce its density, landing ASAP
OVER TENSION (Voltmeter over i 24 V - if present)
1. Master key
- OFF
2. Voltmeter
- VERIFY VOLTAGE REDUCED
3. Master key
- ON
4. Voltmeter
- VERIFY VOLTAGE INSIDE LIMIT
If the problem dont have a solution:
5. Master key
- OFF
6. Electrical equipment not indispensable to flight operations must be turn off.
7. Land ASAP
Note: with battery in good conditions, it is possible continue to flight for 1 hour in complete safety.
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
37 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
38 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
For further information and notes on the maintenances, consult the manual of the emergency
parachute.
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
39 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
SECTION 5
Performance
INDEX
Title
General
Page
40
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
40 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
GENERAL
This section contains all the performance data required for accurate pre-flight planning.
TABLE OF TAKE OFF
Figure 5-1 show the performance of the plane for take off
TABLE OF LANDING
Figure 5-2 show the performance of the plane for landing
PHASES OF TAKE-OFF & LANDING DESCRIPTION SCHEME
Figure 5-3 show the phases of take off and landing description
STANDARD ATMOSPHERE
Significant properties of the ICAO standard atmosphere are tabulated in figure 5-4
DENSITY ALTITUDE
The density altitude chart (figure 5-5) is provided to determine the density altitude for outside air
temperature and pressure altitude combinations. In addition, the reciprocal square root of the
density ratio is given to provide a means of computing the true airspeed from the calibrated airspeed
using the simplified formula: TAS = CAS*(1/d^0.5)
UNIT CONVERSION
Figure 5-6 shows the linear scales for conversion of altitude pressure from (mb) to (inch Hg).
Figure 5-7 shows the linear scales for conversion kilometres / hour (km / h) - KNOTS.
Figure 5-8 shows the linear scales for conversion of the vertical speed (m/sec. - feet/min.)
Figure 5-9 shows the linear scales for conversion of meters (m) / feet (ft).
DEMONSTRATED CROSS WIND COMPONENT
The maximum demonstrated crosswind is 30 Km/h or 16 Knots
Figure 5-10 shows the RELATIVE WIND DIAGRAM VERSUS WIND COMPONENT
DIAGRAMS
Figure 5.11 shows the FLIGHT ENVELOPE
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
41 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
FIGURA 5-1
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
42 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
43 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
FIGURA 5-3
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
44 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
z (ft)
T (C)
T (K)
T/To
Pz (mm Hg)
Pz (mbar)
P/Po
?z (Kg/m^3)
?/?o
-1000
-900
-3280.84
21.5
294.66
1.022
854.475
1139.300
1.124
1.353
1.105
-2952.76
20.85
294.01
1.020
844.609
1126.146
1.111
1.340
1.094
-800
-2624.67
20.2
293.36
1.018
834.836
1113.115
1.098
1.327
1.083
-700
-2296.59
19.55
292.71
1.015
825.155
1100.206
1.085
1.313
1.072
-600
-1968.5
18.9
292.06
1.013
815.564
1087.419
1.073
1.300
1.061
-500
-1640.42
18.25
291.41
1.011
806.069
1074.752
1.060
1.287
1.051
-400
-1312.34
17.6
290.76
1.009
796.654
1062.206
1.048
1.275
1.040
-300
-984.252
16.95
290.11
1.006
787.334
1049.778
1.036
1.262
1.030
-200
-656.168
16.3
289.46
1.004
778.101
1037.468
1.023
1.249
1.020
-100
-328.084
15.65
288.81
1.002
768.954
1025.276
1.011
1.237
1.010
15
288.16
759.9
1013.2
1.225
100
328.084
14.35
287.51
0.997
750.929
1001.239
0.988
1.212
0.990
200
656.168
13.7
286.86
0.995
742.044
989.392
0.976
1.200
0.980
300
984.252
13.05
286.21
0.993
733.245
977.660
0.964
1.188
0.970
400
1312.336
12.4
285.56
0.990
724.530
966.040
0.953
1.176
0.960
500
1640.42
11.75
284.91
0.988
715.899
954.533
0.942
1.165
0.951
600
1968.504
11.1
284.26
0.986
707.352
943.137
0.930
1.153
0.941
700
2296.588
10.45
283.61
0.984
698.888
931.851
0.919
1.142
0.932
800
2624.672
9.8
282.96
0.981
690.506
920.675
0.908
1.130
0.923
900
2952.756
9.15
282.31
0.979
682.205
909.607
0.897
1.119
0.913
1000
3280.84
8.5
281.66
0.977
673.986
898.648
0.886
1.108
0.904
1100
3608.924
7.85
281.01
0.975
665.847
887.796
0.876
1.097
0.895
1200
3937.008
7.2
280.36
0.972
657.787
877.050
0.865
1.086
0.886
1300
4265.092
6.55
279.71
0.970
649.807
866.410
0.855
1.075
0.877
1400
4593.176
5.9
279.06
0.968
641.905
855.874
0.844
1.064
0.869
1500
4921.26
5.25
278.41
0.966
634.082
845.443
0.834
1.054
0.860
1600
5249.344
4.6
277.76
0.963
626.336
835.114
0.824
1.043
0.851
1700
5577.428
3.95
277.11
0.961
618.666
824.889
0.814
1.033
0.843
1800
5905.512
3.3
276.46
0.959
611.073
814.764
0.804
1.022
0.834
1900
6233.596
2.65
275.81
0.957
603.556
804.741
0.794
1.012
0.826
2000
6561.68
275.16
0.954
596.113
794.818
0.784
1.002
0.818
2100
6889.764
1.35
274.51
0.952
588.745
784.994
0.774
0.992
0.809
2200
7217.848
0.7
273.86
0.9503
581.451
775.268
0.765
0.982
0.801
2300
7545.932
0.05
273.21
0.948
574.231
765.641
0.755
0.972
0.793
2400
7874.016
-0.6
272.56
0.945
567.083
756.110
0.746
0.962
0.785
2500
8202.1
-1.25
271.91
0.943
560.005
746.676
0.736
0.952
0.777
2600
8530.184
-1.9
271.26
0.941
553.003
737.338
0.727
0.943
0.769
2700
8858.268
-2.55
270.61
0.939
546.070
728.094
0.718
0.933
0.762
2800
9186.352
-3.2
269.96
0.936
539.208
718.944
0.709
0.924
0.754
2900
9514.436
-3.85
269.31
0.934
532.416
709.887
0.700
0.914
0.746
FIGURE 5-4
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
45 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
Altitude
Feet
Meters
0
0
1.000
305
2.000
610
3.000
914
4.000
1219
5.000
1524
6.000
1829
1.000
2134
8.000
2438
9.000
2743
10.000
3050
11.000
3353
12000
3658
13.000
3965
14.000
4267
15.000
4572
16000
4877
17.000
5182
Temperature
C.
F.
15
59
13,019 55,434
11,038 51,868
9,056
48,301
7,075
44,735
5,094
41,169
3,113
37,603
1,132
34,037
-0,85
30,471
-2,831 26,904
-4,812 23,338
-6,793 19,772
-8,774 16,206
-10,76 12,641
-12,74
9,074
-14,72
5,507
-16,7
1,941
-18,68
-1,625
Relative
Pressure
1
0.886
0.784
0.691
0.608
0.532
0.465
0.405
0.351
0.303
0.260
0.223
0.190
0.161
0.135
0.113
0.094
0.078
FIGURE 5-5
Relative
Density
1
0.904
0.818
0.739
0.666
0.6
0.538
0.481
0.428
0.379
0.333
0.290
0.25
0.212
0.176
0.142
0.111
0.081
Correction
factor
1
1.051
1.105
1.163
1.224
1.290
1.362
1.441
1.527
1.623
1.732
1.855
2
2.171
2.380
2.645
3
3.511
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
46 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
mbar (hPa)
mm Hg
inch Hg
Altezza
mbar (hPa)
mm Hg
inch Hg
-1000
-950
-900
-850
-800
-750
-700
-650
-600
-550
-500
-450
-400
-350
-300
-250
-200
-150
-100
-50
0
50
100
150
200
250
300
350
400
450
500
550
600
650
700
750
800
850
900
950
1000
1050
1100
1150
1200
1250
1139
1132
1126
1119
1113
1106
1100
1093
1087
1081
1074
1068
1062
1055
1049
1043
1037
1031
1025
1019
1013
1007
1001
995
989
983
977
971
966
960
954
948
943
937
931
926
920
915
909
904
898
893
887
882
877
871
854.4
849.5
844.6
839.7
834.8
829.9
825.1
820.3
815.5
810.8
806
801.3
796.6
791.9
787.3
782.7
778.1
773.5
768.9
764.4
759.9
755.4
750.9
746.4
742
737.6
733.2
728.8
724.5
720.2
715.8
711.6
707.3
703.1
698.8
694.6
690.5
686.3
682.2
678
673.9
669.9
665.8
661.8
657.7
653.7
33.6
33.4
33.2
33
32.8
32.6
32.4
32.2
32.1
31.9
31.7
31.5
31.3
31.1
30.9
30.8
30.6
30.4
30.2
30
29.9
29.7
29.5
29.3
29.2
29
28.8
28.6
28.5
28.3
28.1
28
27.8
27.6
27.5
27.3
27.1
27
26.8
26.6
26.5
26.3
26.2
26
25.8
25.7
1300
1350
1400
1450
1500
1550
1600
1650
1700
1750
1800
1850
1900
1950
2000
2050
2100
2150
2200
2250
2300
2350
2400
2450
2500
2550
2600
2650
2700
2750
2800
2850
2900
2950
3000
3050
3100
3150
3200
3250
3300
3350
3300
3350
3400
3450
866
861
855
850
845
840
835
829
824
819
814
809
804
799
794
789
784
780
775
770
765
760
756
751
746
741
737
732
728
723
718
714
709
705
700
696
692
687
683
678
674
670
665.9
661.7
657.4
653.2
649.8
645.8
641.9
637.9
634
630.1
626.3
622.4
618.6
614.8
611
607.3
603.5
599.8
596.1
592.4
588.7
585
581.4
577.8
574.2
570.6
567
563.5
560
556.4
553
549.5
546
542.6
539.2
535.8
532.4
529
525.6
522.3
519
515.7
512.4
509.1
505.9
502.7
499.4
496.2
493.1
489.9
25.5
25.4
25.2
25.1
24.9
24.8
24.6
24.5
24.3
24.2
24
23.9
23.7
23.6
23.4
23.3
23.1
23
22.8
22.7
22.6
22.4
22.3
22.1
22
21.9
21.7
21.6
21.4
21.3
21.2
21
20.9
20.8
20.6
20.5
20.4
20.3
20.1
20
19.9
19.7
19.6
19.5
19.4
19.2
FIGURE 5-6
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
47 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
km/h
1,9
3,7
5,6
7,4
9,3
11,1
13,0
14,8
16,7
18,5
20,4
22,2
24,1
25,9
27,8
29,7
31,5
33,4
35,2
37,1
38,9
40,8
42,6
44,5
46,3
48,2
50,0
51,8
53,7
55,6
57,4
59,3
61,2
knots
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
km/h
63,0
64,9
66,7
68,6
70,4
72,3
74,1
76,0
77,8
79,7
81,5
83,4
85,2
87,1
89,0
90,8
92,7
94,5
96,4
98,2
100,1
101,9
103,8
105,6
107,5
109,3
111,2
113,0
114,9
116,8
118,6
120,5
122,3
FIGURE 5-7
knots
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
km/h
124,2
126,0
127,9
129,7
131,6
133,4
135,3
137,1
199,0
140,8
142,7
144,6
146,4
148,3
150,1
152,0
153,8
155,7
157,5
159,4
161,2
163,1
164,9
166,8
168,6
170,5
172,3
174,2
176,1
177,9
179,8
181,6
183,5
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
48 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
ft/min.
m/sec.
feet/min.
m/sec.
feet/min.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
196.8
393.7
590.5
787.4
984.2
1181.1
1377.9
1574.8
1771.6
1968.5
2165.3
2362.2
2559.0
2755.9
2952.7
3149.6
3346.4
3543.3
3740.1
3937.0
4133.8
4330.7
4527.5
4724.4
4921.2
5118.1
5314.9
5511.8
5708.6
5905.5
6102.3
6299.2
6496.0
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
6692.9
6889.7
7086.6
7283.4
7480.3
7677.1
7874
8070.8
8267.7
8464.5
8661.4
8858.2
9055.1
9251.9
9448.8
9645.6
9842.5
10039.3
10236.2
10433
10629.9
10826.7
11023.6
11220.4
11417.3
11614.1
11811
12007.8
12204.7
12401.5
12598.4
12795.2
12992.1
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
13188.9
13385.8
13582.6
13779.5
13976.3
14173.2
14370
14566.9
14763.7
14960.6
15157.4
15354.3
15551.1
15748
15944.8
16141.7
16338.5
16535.4
16732.2
16929.1
17125.9
17322.8
17519.6
17716.5
17913.3
18110.2
18307
18503.9
18700.7
18897.6
19094.4
19291.3
19488.1
FIGURE 5-8
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
49 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
ft.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
m
10.36
10.66
10.97
11.27
11.58
11.88
12.19
12.49
12.80
13.10
13.41
13.71
14.02
14.32
14.63
14.93
15.23
15.54
15.84
16.15
16.45
16.76
17.06
17.37
17.67
17.98
18.28
18.59
18.89
19.20
19.50
19.81
20.11
ft.
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
FIGURE 5-9
m
20.42
20.72
21.03
21.33
21.64
21.94
22.25
22.55
22.85
23.16
23.46
23.77
24.07
24.38
24.68
24.99
25.29
25.60
25.90
26.21
26.51
26.82
27.12
27.43
27.73
28.04
28.34
28.65
28.95
29.26
29.56
29.87
30.17
ft.
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
50 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
FIGURE 5-10
Flight Manual
Storch HS
(valid for Jabiru 2200 engine version)
Identification:
Page:
Date:
Preparation:
Verification:
Approval:
MV 005 Rev 02
51 of 51
28/apr/2005
M. Fiorindo
R. Ciotti
R. Ciotti
Revision description:
Modified section 5
LEGENDA
Vso
Vs
Vfe
Va
Vc
Vne
58 km/k
64 km/h
105 km/h
127 km/h
162 km/h
205 km/h