BANGLADESH UNIVERSITY OF ENGINEERING & TECHNOLOGY
DEPARTMENT OF MECHANICAL ENGINEERING
9°
‘Course Now: ME 344 (Machine Design 11 Sesslonal)
Date: 22 January, 2014
Problem Class: 01
Class Problems:
82 kW at 2300 apm, isto have a diameter of about
1, The pinion of a pair of steel gear, trans
_, 110mm; Speed ratio, mg = 2.3; 20° FD teeth the drive i 4 6
lel. Decide upon module, face width, number of
irtugal pump, continuous service.
“Material ofthis reduction pair is BS 826M40 H&
teeth
2. A gear manufacturer recommends thatthe following gears (commercially cut) can transmit 19 kW at
indefinite life, moderate shosk, Tp= 31, Ty
(600 rpm of the pinion during continuous 24 hours service,
33 mm, m= 4 mm, 20° FD tooth, pinion material is $30 M40 steel (HT, BHN = 250), gear
70,b
‘material is C.1 and Bronze alloy (S,=650 MPs). At what power you would rate them?
3. 20° fall-depth teeth pinion is to transmit 4 KW at $00 rpm, the velocity ratio= 3, continuous service
is an off ond on reciprocating compressor. Determine the pitch,
and indefinite life. The driven machi
{face width, diameter and the material with treatment (if any). Consi
carefully cut teth