Professional Documents
Culture Documents
2 Passivetransport
2 Passivetransport
Lab 2.2
NaCl does dissociate in water (into Na+ and Cl-), so there are two particles per molecule in
solution.
if osmolarity (OsM) = # particles/mole X # moles/liter, then
OsM of 1 M glucose = 1 particle/mole X 1 mole/liter = 1 OsM, and
OsM of 1 M NaCl = 2 particles/mole X 1 mole/liter = 2 OsM
So, two solutions can have the same molarity but different osmolarities.
The higher the osmolarity, the greater the osmotic pressure of the solution. The greater the
osmotic pressure, the more water is pulled across the membrane.
Because solute concentrations in the body are low they are measured in milli-osmoles (mOsm)
instead of Osm. The osmolarity of body fluids is around 300 mOsm.
Tonicity describes the effect of an extracellular solution on the volume of a cell and is determined
by the relative concentration of nonpenetrating solute molecules. An isotonic solution has the
same concentration of nonpenetrating solutes as the ICF (iso- means same). Some percent
solutions that are isotonic to ICF are 0.9% NaCl and 5.0% glucose. A hypotonic solution has a
lower concentration of nonpenetrating solutes than the ICF (hypo- means below or under), and a
hypertonic solution has a higher concentration than the ICF (hyper- means above or over).
a. If you know the tonicity of a solution you can predict its effect on cells. If you put RBCs into
an isotonic solution, the nonpenetrating solute concentrations on both sides of the membrane are
the same. (For the purpose of these examples, we will assume that the osmolarity of the solutions
is based on nonpenetrating solute concentrations.)
ECF = 300 mOsm
Will osmosis occur? _______________________
Will the cell volume change?_________________
ICF = 300 mOsm
If you put RBCs into a hypotonic solution, the nonpenetrating solute concentration on the outside
of the cell is lower than on the inside.
ECF = 250 mOsm
Will osmosis occur? __________________
In which direction? ___________________
Lab 2.3
We can tell just by looking at suspensions of RBCs whether the cells are intact (normal or
crenated) or hemolyzed. (You cant tell if RBCs are normal or crenated without looking at them
under a microscope.) A suspension of intact RBCs is cloudy, and you cannot see through it easily.
A suspension of hemolyzed RBCs is red but transparent, and you can see through it.
Lab 2.4
intact cells
hemolyzed cells
3) RBCs can be used a) to measure the rate of osmosis, b) to detect differences in the
osmolarity of solutions, and c) to look for permeability changes in the RBC membrane.
When RBCs are incubated in solutions, penetrating solutes can enter the cell. As they do
so, they draw water with them by osmosis. As water enters the cell, the cell swells and
hemoglobin begins to leak out (hemolysis). The faster the solutes enter, the more quickly
hemolysis occurs. What effect would nonpenetrating solutes have on osmosis and
hemolysis?
Absorbance is higher in RBC suspensions that contain whole cells (isotonic and hypertonic
solutions) and lower in RBC suspensions that contain hemolyzed cells (hypotonic solutions).
Another way to say this is that transmittance is lower in RBC suspensions of whole cells and
higher in RBC suspensions of hemolyzed cells.
a. There is a direct relationship between the length of time required for hemolysis to occur and
the rate of osmosis into the cell. The higher the rate of osmosis, the faster hemolysis occurs.
Therefore, the time it takes for hemolysis to occur can be used to indirectly measure the rate of
osmosis. You can do this by monitoring one tube over a period of time while it is in the
spectrophotometer. Absorbance should be high while the cells are still intact, but it should
decrease when the cells hemolyze. The sooner the absorbance decreases, the higher the rate of
osmosis.
b. The osmolarity of various solutions can be assessed by comparing absorbance after adding
RBCs to the solutions. You measure absorbance in each tube--the lower the absorbance, the
greater the degree of hemolysis caused by the solution.
c. The amount of osmosis, measured indirectly by monitoring hemolysis, can be used to detect
changes in RBC membrane permeability under various conditions such as changes in temperature,
pH, and membrane stability. You would use a control tube containing RBCs in isotonic saline and
experimental tubes in which conditions have been altered. Experimental variables that increase
RBC permeability would have higher rates of osmosis and therefore greater hemolysis.
4) Why use red blood cells as models to study osmosis?
a. RBCs are also easy to obtain and work with and the molecular structure of the RBC membrane
is well understood.
Lab 2.5
b. RBCs are capable of either crenation or hemolysis, so they will respond to solutions of
different osmolarities or tonicities. By examining the effect of a solution on the cells, we can tell
whether it is isotonic, hypotonic, or hypertonic.
c. We could use artificial membranes to detect tonicity, but they are made of cellulose with known
pore sizes. They do not contain channels, carriers, or pumps, so they cannot be used to study
membrane transport using those methods.
5) How do lipid solubility and molecular size affect the rate of diffusion of solute molecules
into RBCs?
Lipid soluble (nonpolar) molecules enter cells by diffusing through the lipid bilayer, but molecules
that are not lipid soluble (polar) have to pass through channels. The rate of diffusion of nonpolar
molecules depends on how soluble they are in lipids. The rate of passage of polar molecules
depends on the size of the molecule (which is proportional to its molecular weight). In general,
small nonpolar molecules would pass though a membrane faster than larger, polar molecules.
Lab Activity Instructions: Effect of molecular size and lipid solubility on rate of osmosis.
You will be given 4 solutions labeled A-D. You will observe their effects on hemolysis (and
indirectly on osmosis) to identify the solute present in each solution. You will do this by
comparing the rate of entry of the solute for each solution and using the information in the table
below to infer the identity of the solutes based on their predicted effects.
solute
concentration
molecular
penetration
polarity
weight
glucose
0.5 M
180
permeating
polar
glycerol 0.5 M
92
permeating
nonpolar
sucrose
0.5 M
342
nonpermeating
polar
urea
0.5 M
60
permeating
nonpolar
Lab 2.6
then every 60 seconds through minute 15 to see if it becomes clear. Record status in the data
chart at each time check.
6) Repeat step 5 for tubes B, C and D, but only if you have enough people in your group for each
person to time one tube.
7) Cleanup and disposal:
a. tubes
1. empty tube into hazardous waste container
2. rinse tube with 1 mL water and empty into hazardous waste container
3. put empty tube into broken glass box
b. gloves and plastic pipets go into regular trash
c. glass pipets go into tub in sink
d. wipe table with soapy water
time
blood
added
unknown A
10 sec
20 sec
30 sec
40 sec
50 sec
1 min
10 sec
20 sec
30 sec
40 sec
50 sec
2 min
unknown B
unknown C
unknown D
Lab 2.7
3 min
4 min
5 min
6 min
7 min
8 min
9 min
10 min
11 min
12 min
13 min
14 min
15 min
Questions
1. What kind of solute enters the RBC faster: small or large?
2. What kind of solute enters the RBC faster: polar or nonpolar?
3. What kind of solute should cause hemolysis faster: small or large?
4. What kind of solute should cause hemolysis faster: polar or nonpolar?
5. Which unknown solute was the smallest and least polar: A
6. Which unknown solute was nonpermeating: A
7. Which solution should cause hemolysis sooner (Assume the membrane is equally permeable to
all ions); 0.5 M NaCl or 0.5 M CaCl2?
8. Osmolarity measures the number of solute _____________ per liter of solution.
9. Tonicity is determined by the relative concentration of ________________ solute molecules in
an extracellular solution.
1) Observations:
a. Permeating solutes enter RBCs (faster/slower) than nonpenetrating solutes.
b. Small solutes enter RBCs (faster/slower) than large solutes.
c. Polar solutes enter RBCs (faster/slower) than nonpolar solutes.
d. The higher the rate of osmosis, the (higher/lower) the rate of hemolysis.
2) Predictions:
Lab 2.8
a. If osmosis occurs in solutions of small solutes before it occurs in solutions of large solutes,
then hemolysis should occur in glucose (before/after?) it occurs in glycerol.
b. If osmosis occurs in solutions of nonpolar solutes before it occurs in solutions of polar solutes,
then hemolysis should occur in glycerol (before/after?) it occurs in glucose.
c. If osmosis does not occur in solutions of nonpermeating solutes, then hemolysis (will/will not)
occur in the sucrose solution.
3) Based on the information you have been given, rank the 4 solutes on their expected rate of
entry into the RBCs:
fastest:
slowest:
.