Professional Documents
Culture Documents
3CE01 Civi Engg Unit-III
3CE01 Civi Engg Unit-III
b) m + 3 < 2j
c) m +3 > 2j
d) b and c both
(b)
b) m + 3 < 2j
c) m +3 > 2j
d) b and c both
(c)
b) Tie
c) Column
(d) None
(b)
b) Tie
c) Column
(d) None
(A)
Q5. Which one of the method is used to find the forces in few members?
a) Method of joint
b) Method of Section
c) Graphical Method
d) All of these
(b)
Q6. Which one of the method is used to find the forces in ALL members?
a) Method of joint
b) Method of Section
c) Graphical Method
d) All of these
(A)
b) spatial truss
c) both a & b
d) none
(c)
b) deficient truss
c) redundant truss
d) none
(b)
d) none
(A)
d) none
(C)
d) none
(A)
d) none
(b)
d) none
(C)
b) deficient truss
c) redundant truss
b) deficient truss
c) redundant truss
b) deficient truss
c) redundant truss
b) deficient truss
c) redundant truss
b) deficient truss
c) redundant truss
Q14. The center of gravity of an equilateral triangle with each side(a)..from any of the three sides
a 3
2
a)
a 2
2
b)
a
2 3
c)
a
3 2
d)
(c)
Q15. The centre of gravity of hemisphere lies at a distance offrom its base measured along the vertical radius.
3r
8
a)
3
8r
b)
8r
3
c)
8
3r
d)
(a)
Q16. The centre of gravity of right circular cone of diameter (d) and height (h) lies at the distance of ..from the
base measured along the vertical radius.
h
2
a)
h
3
b)
h
4
c)
h
6
d)
(c)
Q17. A circular hole of radius(r) is cut out from a circular disc of radius (2r) in such a way that the diagonal of the
hole is the radius of the disc.The centre of gravity of the section lies at
a) Centre of a disc
b) Centre of the hole
c) Somewhere of the disc
d) Somewhere in the hole
(c)
Q18. If the area of a section is in mm2 and he distance of the centre of area from a lines is in mm,Then units of the
moment of inertia of the section about the line is expressed in
a) mm2
b) mm3
c) mm4
d) mm5
(c)
Q19. Theorem of perpendicular axis is used in obtaining the moment of inertia of a
a) Triangular lamina
b) Square lamina
c) Circular lamina
d) Semicircular lamina
(b)
Q20. The moment of inertia of a circular section of diameter (d) is given by the relation
16
a)
d4
32
b)
d4
64
c)
d4
96
(c)
d)
d4