Professional Documents
Culture Documents
1978 Johnson 55 HP Outboard Service Manual PDF
1978 Johnson 55 HP Outboard Service Manual PDF
506997
LITHO U.S.A.
INSTALLATION
a. Install the power pack ground wire, and position
the wire so there will be no pull (stretch) when the
power pack is installed. Excessive pull on the
ground wire could result in ignition failure. See
Figure 4 -44.
b. Mount the power pack and tighten the screws to
the torque specified in Section 2.
, . , NOTE
Carefully align the connector halves during
assembly to provide proper terminal contact.
c. Reconnect the three wire and four wire connectors, and secure each connector with a retainer.
REMOVAL
83100
b. Mount the ignition coil to the eng'ine with the lockwasher between the engine block and ground wire
connector. See Figure 4-47.
c. Secure the high tension lead to the spark plug.
U'fuT,fn NOTE
Carefully align the comlector halves during
assembly to provide proper terminal contact.
d. Reconnect the three wire connector, and secure
with retainer.
1.
2.
3.
4.
5.
Spring terminal
Cover (twist and pull)
Hook
High tension lead
Spark plug
Ull@INOTE
To insure proper ignition timing check the
No. 1 (TOP) ignition coil orange lead to be
sure it is in the "B" terminal of the connector, and that it connects to the orange/blue
stripe wire from the power pack.
53073
4-21
Remove bearing setscrew from gearcase before attempting lower driveshaft bearing removal. See Figure 6-23 insert.
RETAINER
SPRING
PIN
FORWARD
GEAR
BEARING
HOUSING
53146
6-9
Searches for
finding year of 35 Johnson sea horse, Johnson 25 HP cyl.
outboard motor, 1978 johnson 70 hp operation, wiring diagram
for 1987 Evinrude 70 HP, Johnson 35 HP manual, 1968 65 HP
Johnson outboard, wiring diagram for tilt and trim motor,
Johnson Evinrude thermostat 5-235HP, 1973 - 1989 Johnson
outboard repair, owner and part manual, 55 HP Johnson
outboard manual pdf eBook 55 HP Johnson outboard manual,
1969 Johnson 85 HP wiring diagram, Evinrude Johnson repair