Professional Documents
Culture Documents
User Manual: UDB130xS Seriers Two Channel DDS Signal Generator
User Manual: UDB130xS Seriers Two Channel DDS Signal Generator
User Manual
Rev1.0
2012-12-15
-1-
-2-
Function description
-3-
Operating Guide
1. Pressing the "Select" key which can switch from frequency adjusting
to function adjusting, and the detailed condition (frequency adjusting
or function adjusting) display and after "*".
step frequency:0.01kHz
-4-
(WAVE=SQR)
(WAVE=SQR)
(WAVE=TRI)
(WAVE=TRI)
(WAVE=TRI)
8. SAVE can save the value of the current frequency, wave and duty, and
there are 10 storage position from M0 to M9, which adjusted by code
switch, as setting finished, then press "OK" key, when "OK" appeared
on the screen, storage is over. If the current value is saved to M0,
and the changed value will be called in next time, to UDB130xS series,
the start frequency of sweep function is defined at M1, the end frequency
is defined at M2. If the sweep function need to be run, the start and
-5-
(set posion)
12. TTL output the synchronized TTL wave of the same frequency.
13. AB channel switching key.When AB channel output signal need
adjust,use switching key,if adjust channel B output signal parameter,
press CH(A/B) key,channel B indicator light lighting, Regulation
encoder only channel B frequency change,channel with A won't change.
14. Tracking control function,use this function must ensure that
channel A control mode,channel A indicator light lighting, press"OK"
key,switch *FUNC:TRACE=ON, adjust frequency channel A and channel B
change at the same time.
List:
1. DDS function generation / counter
1PCS
2. DC 5V Power supply
1PCS
3. User's manual
1PCS
-6-