Professional Documents
Culture Documents
Packing Folder Tutorial and Pattern
Packing Folder Tutorial and Pattern
cen
ter
i
ngt
hef
l
ap)
D I Y P ac ki n g Fo l d e r Tuto r i a l
Linda Jamar & Jana B runken
June 2010
Ma te rial s Needed:
A s sembly of Patte rn :
In st ructions:
3. Sandwich the edges between the folded bias tape and stitch with a zig-zag
stitch around curved edge leaving straight edge free.
4. Center the Sticky side of Velcro on solid utility fabric and stitch in place.
5. Center the soft side of the Velcro on the mesh fabric and stitch in place.
6. Center one side of the other piece of Velcro on the end of the body and stitch
in place. Repeat with other piece on the body lining.
7. Place the ends of the nylon webbing on the indicated spots on the side flap and
baste in place.
8. With right sides together, stitch around the curved edge of the side flap,
using a ½” seam.
9. Stitch side flaps on each side of the body, where indicated using a 5/8”
seam.
10. Turn and press.
11. With right sides together, sew the body to the lining, leaving the mesh side
flap free.
12. Turn right side out and press well. Turn under raw edge and press.
(Lining)
(Front)
13. Draw a pencil line from the top of one flap across the body to the top of the
other side flap. Stitch along that line and topstitch around ends of the body.
(long flaps)
14. Slide interfacing piece inside the “box” (trim if necessary). Topstitch the
free edge closed.
15. Trim the plastic cutting board to approximately 8” x 14” to use as a folding
board.
16. VOILA’!!!!