Professional Documents
Culture Documents
ECS 3041 Structure and Materials Laboratory
ECS 3041 Structure and Materials Laboratory
REBOUND HAMMER
PROGRAMME
EV101
SEMESTER
GROUP MEMBERS
LECTURER
05
1
2
SECTION
03
DATE
9/8/2016
PTM140709051
PTM140708516
4
5
PTM140708619
PTM140708636
PTM140708669
TABLE OF CONTENT
NO
1
2
3
4
5
6
7
8
9
CONTENTS
INTRODUCTION
OBJECTIVES
APPARATUS
PROCEDURES
CALCULATION
DISCUSSION
CONCLUSION
REFERENCES
APPENDIX
1. INTRODUCTION
PAGES
2. OBJECTIVES
3. APPARATUS
4. PROCEDURES
1. A two square about 300x300mm each have been made on different surfaces.
2. 12 points have been marked at each square.
3. The rebound hammer was positioned at an impact point and was pressed
strongly and steadily against the concrete surface at right angle and the rebound
hammer was locked.
4. The reading record was taken based on the rebound hammer reading.
5. The test at each point in both squares was repeated.
6. The compressive strength of each reading and the average were calculated.
7. CALCULATION
8. DISCUSSION
9. CONCLUSION
10.
REFERENCES
11. APPENDIX