Professional Documents
Culture Documents
Digital Logic Circuit Design
Digital Logic Circuit Design
Digital Logic Circuit Design
Submitted to
Ms.Najnin Sultana
Senior Lecturer
Department of ETE
Daffodil International University
Submitted by
Md. Sihab Talukdar
ID=101-19-1196
Department of ETE
Daffodil International University
Objectives
1. Introduce students on using proteus software.
2. Introduce how to run simulation of designed digital circuit.
3. Understand how to applied digital logic equation to real hardware designs.
Related Theory
Proteus has many features to generate both analogue and digital result. However, this lab will
focus on only tools that will be used in digital schematic designs.
Proteus tools:
Parts Browsing
Proteus has many models of electronic equipments such as logic gates, many kinds of switches
and basic electronic devices.
These equipments can be founded by clicking on
and then
. Then, a new window will
pop up and wait for the parts information as shown in the Figure 2.
Figure 4
Figure 5
LOGIC STATE
In addition, there is another input that usually be used in digital circuit designed system but it
does not exist in real world as an equipment. It is called as LOGIC STATE. It can be found in
picking part section (typing logicstate and pick it.)
to run and
to stop.
Note
Actually, the digital result on proteus can be seen in small square at the pin of the equipments and
the state will be shown in 4 colors (red = logic 1, Blue = logic 0, Grey = Unreadable logic
and Yellow = Logic congestion).
Class Example
Connect the following circuit on PROTEUS and then simulate it; after that find the truth table
using PROTEUS program, also find the truth table manually and then compare the two results
together:
B
0
0
1
1
0
0
1
1
C
0
1
0
1
0
1
0
1
G
1
0
0
1
1
0
0
0
Input is A = 0, B = 0, C = 1
Input is A = 0, B = 1, C = 0
Input is A = 0, B = 1, C = 1
Input is A = 1, B = 0, C = 0
Input is A = 1, B = 0, C =1
Input is A = 1, B = 1, C = 0
Input is A = 1, B = 1, C = 1
c) We note that the results are identical for both the manual and PROTEUS.
Class Example
Follow the procedure used in the previous example, solve the following example, and then show
the result to your Lab Instructor.
Exercise (Report)
For the previous experiment; solve all the parts using PROTEUS and include the results in your
report.
Md.Sihab Talukdar