This document describes a protection current transformer (CT) with a rated primary current of 200A and rated secondary current of 5A. It has an accuracy load of 15VA and an accuracy limit factor of 10. The CT has an accuracy of 5% or less at 10 times the rated current, as long as the real load consumes 15VA at the rated current. However, the document notes that these data alone are not sufficient and it would also be useful to know the standard values for this CT.
This document describes a protection current transformer (CT) with a rated primary current of 200A and rated secondary current of 5A. It has an accuracy load of 15VA and an accuracy limit factor of 10. The CT has an accuracy of 5% or less at 10 times the rated current, as long as the real load consumes 15VA at the rated current. However, the document notes that these data alone are not sufficient and it would also be useful to know the standard values for this CT.
This document describes a protection current transformer (CT) with a rated primary current of 200A and rated secondary current of 5A. It has an accuracy load of 15VA and an accuracy limit factor of 10. The CT has an accuracy of 5% or less at 10 times the rated current, as long as the real load consumes 15VA at the rated current. However, the document notes that these data alone are not sufficient and it would also be useful to know the standard values for this CT.
This document describes a protection current transformer (CT) with a rated primary current of 200A and rated secondary current of 5A. It has an accuracy load of 15VA and an accuracy limit factor of 10. The CT has an accuracy of 5% or less at 10 times the rated current, as long as the real load consumes 15VA at the rated current. However, the document notes that these data alone are not sufficient and it would also be useful to know the standard values for this CT.
Its accuracy limit factor is ALF = 10 For I = ALF. In, its accuracy is 5% (5P), (see figure 1) To simplify, for the protection CT given in example, the ratio error is less than 5% at 10 In , if the real load consumes 15 VA at In. However these data are not sufficient. Also, it is useful to know the standard values.