Professional Documents
Culture Documents
InteliLite - GPRS Communication Module - 1.0 (Proof) - FAQ - 2
InteliLite - GPRS Communication Module - 1.0 (Proof) - FAQ - 2
InteliLite - GPRS Communication Module - 1.0 (Proof) - FAQ - 2
InteliLite
GPRS Communication Module
Revision: 2.0
Date: 17.6.2015
Table of Contents
1
Preface ..................................................................................................................... 2
1.1
1.2
Installation ................................................................................................................ 3
2.1
2.2
Connections ....................................................................................................... 4
1 Preface
GPRS is a plug-in communication module for controllers IL-NT, IC-NT, ID-Lite, and the
ID-FLX platform which provides wireless connectivity. The following protocols are
available:
ComAp proprietary protocol for wireless connection of ComAp PC programs such
as LiteEdit and InteliMonitor.
AirGate support
WebSupervisor support
LiteEdit
Power supply for IL-NT-GPRS plug in card (8-36 volt DC, same as power supply
of controller)
GSM Antenna
o Operating Frequencies - 850, 900, 1800, and 1900 Hz
o SMA Connector
Hint: Used SIM card must be unlocked. Any manipulation with the plug-in module shall
be done with disconnected power supply to controller and module.
2 Installation
2.1 GPRS Module
For correct installation of the module please follow the guide:
2.2 Connections
POWER SUPPLY
ANTENNA
SIM CARD
Picture 3. IL-NT-GPRS.
Power up the system (controller and module together) and wait 2-4 minutes for
the first connection of the system to AirGate. AirGate will generate automatically
the AirGate ID.
Test settings using the last measurement screen. Verify the following.
Signal Strength
AirGate ID
If an error is present on the GPRS network a number will be displayed in the GSM Diag
Code. Please see table below.
Table 1. GSM Diag Codes.
Code
0
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
Description
OK. No error.
Not possible to hang up.
IL-NT-GPRS is switched off
IL-NT-GPRS is switched on
IL-NT-GPRS error in initialization
IL-NT-GPRS not possible to set the APN
IL-NT-GPRS not possible to connect to GPRS network
IL-NT-GPRS not possible to retrieve IP address
IL-NT-GPRS not accepted DNS IP address
Error in modem detection
Error in initialization of analog modem
SIM card is locked (Possibly PIN code required, PIN needs to be deactivated) or
unknown status of SIM locking
No GSM signal
Not possible to read the SIM card parameters
GSM modem did not accepted particular initialization command, possibly caused by
locked SIM card
Unknown modem
Bad answer to complement initialization string
Not possible to read GSM signal strength
CDMA modem not detected
No CDMA network
Unsuccesful registration to CDMA network
In case of GSM Diagnostic code different from 0, please contact the operator of your
SIM card services for the proper GPRS APN settings. You will need following to fill in
the setpoints:
Enter correct APN settings in the setpoints group Comms Settings. Obtain access
using either the front display (Engineer Mode) or using LiteEdit 4.5 or higher.
If the connection is succesfull, you will see following picture 5 with airgate ID. This
screen is on the last position in the main menu.
Airgate ID you can use for InteliLite InteliMonitor and WebSupervisor connection.
Please note, that GPRS connection do note provide IP Address. There are no
possibilities for Modbus connection.
Controller cannot be reprogram with LiteEdit, you will not be able to do this
procedure.
ComAp a.s.
Kundratka 2359/17, 180 00, Prague 8, Czech Republic
(+420) 246 012 111
www.comap.cz