MW
HHEANWece] 600W Single Output Power Supply
SPECIFICATION
opeL
ourrur
Input
PROTECTION
‘uoNHENT
SAFETY
ewe
OTHERS
Note
Features
AC input active surge current limiting
* AC input range selected by switch
Protections:Short circuit ’ Overlo
+ Forced air cooling by builtin DC tan
+ High power density 4.9"
* Builtin remote sense function
+ UL approved
* Low cost
+ 2years warranty
Over voltage / Over temperature
A:
De voLTAGE ro
RATED CURRENT 50k
(CURRENT RANGE 0-508
RATED POWER soa
RIPPLE & NOISE (ax) Note2 ssonvep
VOLTAGE ADJ. RANGE 10-158
VOLTAGE TOLERANCE nte3 ENG
LINE REGULATION 105%
LOAD REGULATION 105%
SETUP, RISE TE s,s 230 ns, rs VAC at load
HOLD UP TIME (Typ,) 20ms!230VAC_ ‘t6ms/115VAC at full load
VOLTAGE RANGE 50 1020RC 10 ~ 250 2
FREQUENCY RANGE |47~63H
EFFICIENCY (6) oF 7% fe
[AC CURRENT (Typ) TONHTEVAC_ TSNSGVAC
IWRUSH CURRENT (yp) 2oarIsva Lala
LEAKAGE CURRENT | <20mA/240VAC
105 = 126% te ut poner
‘OVERLOAD Protection type : Shut down olp voltage, re-power on to
fise~162v_|
reac) Protection type : Shut down ofp voltage, re-power on to recover
256256 (TSW dele on eas power rarest
OVER TEMPERATURE tection tyge : Shut down olp voltage, recovers automatically after temperat yes cOWn
WORKING TEWR. -20- #60 (Relerto opie erating cune)
WORKING HUMIOTY = 9% RH non congensing
[STORAGE TEMP, HUMIDITY | 40~ #85, 10~95% RH
TEMP COEFFICIENT 10.05% (0500)
VIBRATION 10 500H2, 26 10min cyte, 60min. each along X,Y, Zaxes
SAFETY STANDARDS: UL50950-1aparoves
WITHSTAND VOLTAGE | UP-OIPSKVAC_UP-FG:SKVAG Ol
ISOLATION RESISTANCE —_IP-OVP,1>-F, IP-FG:" 00M Ohms
MTBF
197Khrsmin, —MIL-HOBK217F (25°C)
DINENSION 17°63 5mm (LH)
PACKING 2.1K; 6pcsit3.4Kgit OBCUFT
1. All parameters NOT specially mentioned are measured at 230VAG input, rated load ara 25. of ambient temperature
2. Ripple & ncise are measured at 20M of bandwieth by using a 12" lwssles pair-wire terminated with aO.1u! & 47ul parallel capacitor
2. Tolerance
eludes sat up Lolerance, in regulalion and load regulation,