This document outlines a test method for measuring the solar absorptance, reflectance, and transmittance of materials using an integrating sphere spectrophotometer. Spectral measurements are taken from 300 to 2,500nm and used to calculate weighted solar properties. The test procedure involves recording 100% and zero reference curves with an absorber or blocked sample beam. Reflectance is calculated differently for opaque versus transparent/translucent materials based on their position in the integrating sphere and amount of light entering.
This document outlines a test method for measuring the solar absorptance, reflectance, and transmittance of materials using an integrating sphere spectrophotometer. Spectral measurements are taken from 300 to 2,500nm and used to calculate weighted solar properties. The test procedure involves recording 100% and zero reference curves with an absorber or blocked sample beam. Reflectance is calculated differently for opaque versus transparent/translucent materials based on their position in the integrating sphere and amount of light entering.
This document outlines a test method for measuring the solar absorptance, reflectance, and transmittance of materials using an integrating sphere spectrophotometer. Spectral measurements are taken from 300 to 2,500nm and used to calculate weighted solar properties. The test procedure involves recording 100% and zero reference curves with an absorber or blocked sample beam. Reflectance is calculated differently for opaque versus transparent/translucent materials based on their position in the integrating sphere and amount of light entering.
Solar Absorptance, Reflectance and Transmittance of Materials Using
Integrating Spheres. This test method covers the measurement of spectral absorptance, reflectance and transmittance of materials using spectrophotometers equipped with integrating spheres. It will also cover the methods used of computing solar weighted properties from the measured spectral values. For this test measurements of transmittance (or reflectance) are made over the spectral range
from
approximately
300
to
2,500nm
using
an
integrating
sphere
spectrophotometer. The specimen can be patterned, opaque, transparent or slightly
translucent and can vary in size depending on the integrating sphere being used for measurements. The solar absorptance can be explained in terms of a ratio where 1 is the maximum amount of solar heat gain that can come through a skylight and 0 is the least amount. Therefore, a solar heat gain coefficiency of 0.40 means that 40% of the available solar heat is coming through the entire skylight unit. During the test the 100% and zero line curves should be recorded. For reflectance measurements, record the zero line with a perfect absorber or light trap in the sample port. For transmittance measurements, record the zero line with the sample beam blocked, preferably as far in front of the entrance port as convenient. Reflectance of opaque and transparent or translucent materials is calculated differently to each other by means of position in the integrating sphere and amount of light being allowed to enter the sphere.