COUPLINGS, GEAR TRAINS,
AND
V-BELT DRIVES
Section 3
V-Belt DrivesSECTION 3
V-BELT DRIVES
Introduction
1. ‘This electric motor is going to be used as the prime
mover for this compressor
‘the prime mover and the driven equipment are placed
(end-to-end side-to-side). side-to-side
2. A flexible coupling such as a plastic block or rubber
tire coupling (can/eannot) be used to join the two cannot
shafts,
4. Which of these three methods of joining the shafts
may be used to couple that electric motor and com-
‘pressor?
646
te
‘The shafts may be joined by a gear train or by a V-
belt drive,
Since the shafts are so fi
gear train) is more pract
ipart, the (V-belt drive/
A V-belt is a simple device for transmitting power
between two parallel shafts.
A sheave (wheel) is mounted on each —___.
‘The sides of the sheave form a groove.
‘The ____ rides in this groove.
Name the parts of this V-belt drive,
V-belt drive
shatt
V-belt, or belt
A, shaft; B. groove
G, sheave; D. V-belt