Professional Documents
Culture Documents
Acqbankfornoticeboard
Acqbankfornoticeboard
ENGINEERING
R.V. COLLEGE OF ENGINEERING, BANGALORE 560059
Question bank for Analog communication lab
2a Design a second order Butterworth active low pass filter for a given cut-off
frequency. fc=_______Hz ( less than 10KHz). Conduct an experiment to draw the
frequency response and verify the roll-off.
b Verify sampling theorem. Demonstrate over sampling and under sampling.
3a Design a second order Butterworth active notch filter for the assumed notch
frequency.
b Obtain Time division multiplexed signal using IC CD4051 and plot the
waveforms.
4a Using IC 1496, rig up a Balanced modulator circuit. Test its operation & record
the waveforms showing the Phase reversal.
b Design a second order Butterworth active High pass filter for a given cut-off
frequency fc=_______Hz . Conduct an experiment to draw the frequency
response and verify the roll-off.
5a Using IC 1496, rig up a balanced modulator circuit. Test for DSBSC operation &
record the waveforms.
b Conduct an experiment to generate Lower side band of SSBSC.
6a Conduct an experiment to generate PWM signal and record the maximum and
minimum pulse width.
b Generate PPM waveform signal and calculate the pulse width.
8a Design a transistor mixer circuit and demonstrate the mixing action (Up & Down)
for an IF of 455 KHz.
b Design FM modulator and demodulator .Simulate the design using Simulink
Calculate the Frequency deviation.
12 a Design and conduct an experiment to test de-emphasis circuit and plot the
frequency response.
b Design FM modulator and demodulator. Simulate the design using Simulink.
13a Design FM modulator and demodulator. Simulate the design using Simulink
b Design and conduct an experiment to test pre-emphasis circuit and plot the
frequency response.
14a Obtain Time division multiplexed signal using IC CD4051 and plot the
waveforms
b Design and conduct an experiment to test pre-emphasis circuit and plot the
frequency response.
15a Obtain Time division multiplexed signal and demultiplexed using IC CD4051
and plot the waveforms
b Design FM modulator . Simulate the design using Simulink and calculate the
bandwidth
16a Conduct an experiment to generate PWM signal and record the maximum and
minimum pulse width.
b Design AM modulator. Simulate the design using Simulink and plot the
waveforms.
20a Design a transistor mixer circuit and demonstrate the mixing action (Up & Down)
for an IF of 455 KHz.
b Design AM modulator and demodulator. Simulate the design using Simulink and
plot the waveforms.
21a Conduct an experiment to generate an AM signal using collector modulation for an
fc= _______KHz and fm=_______Hz. Plot the variations of modulating signal
amplitude V/S modulation index.
b Design AM demodulator for the above specifications and simulate using
SIMULINK
Plot the variations of modulating signal amplitude V/S modulation index of
Part a & Part b .Compare the results
22a Obtain Time division multiplexed signal and demultiplexed using IC CD4051 and
plot the waveforms
b Design AM modulator. Simulate the design using Simulink and obtain modulation
index