Professional Documents
Culture Documents
MD200 Series User Guide 02-06-12
MD200 Series User Guide 02-06-12
ANATEL ANNEX to Resolution No. 303 of July 2, 2002. Potentially Explosive Atmospheres Removing the NiMH Battery Pack
Turn off your radio prior to entering any area with a potentially explosive
Control Buttons
ANATEL ANNEX to Resolution No. 533 of September 10, 2009. 1. Turn the radio off.
atmosphere. Only radio types that are especially qualified should be used
To ensure optimal radio performance and make sure human exposure 2. With the back of the radio facing you, lift the battery latch up to
in such areas as Intrinsically Safe. Do not remove, install or charge
to radio frequency electromagnetic energy is within the guidelines set release the battery cover and remove the cover.
batteries in such areas. Sparks in a potentially explosive atmosphere can
forth in the above standards, always adhere to the following 3. Gently remove the NiMH battery by easing it out.
Two-Way Radio cause an explosion or fire resulting in bodily injury or even death.
procedures.
Note: The areas with potentially explosive atmospheres referred to above 4. Reposition the battery cover and press down to secure.
User Guide Portable Radio Operation and EME Exposure Line Drawing best fitting for UG
include fueling areas such as below decks on boats, fuel or chemical
Antenna Care transfer or storage facilities, areas where the air contains chemicals or Removing the Three AA Alkaline Batteries (Optional Accessory)
Use only the supplied or an approved replacement antenna. particles (such as grain, dust or metal powders) and any other area 1. Turn the radio off.
Unauthorized antennas, modifications, or attachments could damage where you would normally be advised to turn off your vehicle engine. 2. With the back of the radio facing you, lift the battery latch up to
the radio and may violate FCC regulations. Areas with potentially explosive atmospheres are oftenbut not release the battery cover and remove the cover.
Do NOT hold the antenna when the radio is IN USE. Holding the alwaysposted. PTT
3. Remove each alkaline battery by easing each battery out
antenna affects the effective range. Blasting Caps and Areas
e: Aug 26, 2011_Rev.1 Body-Worn Operation To avoid possible interference with blasting operations, turn off your
individually.
4. Reposition the battery cover and press down to secure.
del: MD200 To maintain compliances with FCC/Health Canada RF exposure radio when you are near electrical blasting caps, in a blasting area, or in
guidelines, if you wear a radio on your body when transmitting, always areas posted Turn off two-way radios. Obey all signs and instructions.
Notes:
scription: Line Drawing with point lines place the radio in a Motorola-supplied or approved clip, holder, holster,
case or body harness for this product. Use of non-Motorola-approved
Operational Cautions
PTT
Exercise care when removing NiMH or AA batteries. Do not use
PTT
For More Information The Advanced Medical Technology Association recommends that a release the catch.
and shape as those on the plug of the charger.
minimum separation of 6 inches (15 cm) be maintained between a
For further information, you may call Motorola Solutions, Inc. at The extension cord is properly wired and in good electrical condition. 2. Pull the belt clip away fromPTT
the back of the radio.
handheld wireless radio and a pacemaker. These recommendations are
1-800-638-5119 (U.S. and Canada), e-mail us at giantintl@callcenter.com consistent with the independent research by and recommendations of Turning Your Radio On and Off
The extension cord size is 18 AWG for lengths up to 100 feet, and
or visit us on the Internet at www.motorolasolutions.com. the U.S. Food and Drug Administration. 1. To turn on, press and hold until a channel number appears
16 AWG for lengths up to 150 feet.
People with pacemakers should: and the radio beeps.
9. The supply cord of the AC adaptor cannot be replaced. If the cord is
ALWAYS keep the radio more than 6 inches (15 cm) from their damaged, call customer service at 1-800-638-5119 or e-mail us at
PTT
2. To turn off, press and hold until the display goes blank.
Safety and General Information pacemaker when the radio is turned ON. giantintl@callcenter.com. Setting the Volume
Date: Aug 26, 2011_Rev.1
PTT Press to increase
Not carry the radio in the breast pocket. Model: or
MD200 to decrease the volume. The volume level
Important Information on Safe and Efficient Operation Description:
flashes and VOL displays.Line Drawing with point lines
Date: Aug 26, 2011_Rev.1
Read This Information Before Using Your Radio.
Use the ear opposite the pacemaker to minimize the potential for Licensing Information Scale 1 : 1 for radio size
interference. Model: MD200
The information provided in this document supersedes the general Description: Line Drawing with point lines
Turn the radio OFF immediately if there is any reason to suspect that Your Motorola radio operates on FRS & GMRS frequencies in Canada & Talking and Listening
Scale 1 : 1 for radio size
safety information in user guides published prior to December 1, 2002.
interference is taking place. in the USA. For Canadian citizens, use of these frequencies is subject to Getting Started
Transmit and Receive Procedure Medical Devices Hearing Aids the rules & regulations of Industry Canada (IC). IC requires no license To communicate, all radios in your group must be set to the same
Your two-way radio contains a transmitter and a receiver. To control when operated in Canada. For USA citizens, use is subject to the rules Installing the Batteries channel.
Some digital wireless radios may interfere with some hearing aids. In
your exposure and ensure compliance with the general and regulations of the Federal Communications Commission (FCC) . The Each radio uses 1 NiMH rechargeable battery pack or 3 AA alkaline
the event of such interference, you may want to consult your hearing 1. To talk, press and hold PTT .
population/uncontrolled environment exposure limits, always adhere to FCC requires that all operators using GMRS frequencies obtain a radio batteries and beeps when the batteries are low.
aid manufacturer to discuss alternatives. 2. When you are finished talking, release PTT .
the following procedure: license before operating their equipment. To obtain the FCC forms, please
Medical Devices - Other visit the FCCs Web site at wireless.fcc.gov/uls/index.htm?job=home to Installing NiMH Rechargeable Battery Pack For maximum clarity, hold the radio two to three inches away from your
Transmit no more than 50% of the time. If you use any other personal medical device, consult the manufacturer source form 605 and 159, which includes all the instructions you will mouth and speak directly into the microphone. Do not cover the
1. Turn the radio off.
To receive calls, release the Push-to-Talk (PTT) button. of your device to determine if it is adequately shielded from RF energy. need. If you wish to have the document faxed or mailed, or if you have microphone while talking.
Your physician may be able to assist you in obtaining this information. 2. With the back of the radio facing you, lift the battery latch up to
To transmit (talk), press the PTT button. questions, please use the following contact information:
Safety and General Use While Driving release the battery cover and remove the cover. Talk Range
Transmitting 50% of the time, or less, is important because the radio For a fax: For mail service: If you have 3. Remove the NiMH battery pack from the clear plastic bag (do not Your radio is designed to maximize performance and improve
Check the laws and regulations regarding the use of radios in the area
generates measurable RF energy exposure only when transmitting (in where you drive, and always obey them. If you do use your radio while
Contact the Call the FCC questions about disassemble or unwrap the battery pack). transmission range. Do not use the radios closer than five feet apart.
terms of measuring standards compliance). driving, please: Fax-0n-Demand Forms Hotline the FCC License:
system Call the FCC 4. Insert the NiMH battery pack with the diagram facing you. Note: This radio does not have Interference Eliminator Codes. To
Exposure to Radio Frequency Energy Give full attention to driving and to the road. 5. Reposition the battery cover and press down to secure. communicate with radios that use Interference Eliminator Codes, the
Your Motorola two-way radio complies with the following RF energy Use hands-free operation, if available. 1-202-418-0177 1-800-418-FORM 1-888-CALL-FCC Interference EliminatorPTTCode must be set to 0.
exposure standards and guidelines: (3676) (225-5322) Installing the Three AA Alkaline Batteries (Optional Accessory)
Pull off the road and park before making or answering a call if driving
United States Federal communications Commission, Code of Federal 1. Turn the radio off. Monitor Button PTT
conditions so require. Changes or modifications not expressly approved by Motorola may void Pressing and holding for three seconds allows you to listen to the
Regulations; 47CFR part 2 sub-part J.
The use of a two-way radio while engaged in activities requiring the users authority granted by the IC/FCC to operate this radio and 2. With the back of the radio facing you, lift the battery latch up to
American National Standards Institute (ANSI)/Institute of Electrical volume level of the radio when you are not receiving. This allows you to
concentration may cause distraction or otherwise impair your ability to should not be made. To comply with IC/FCC requirements, transmitter release the battery cover and remove the cover. adjust the volume, if necessary. You can also press to check for
and Electronic Engineers (IEEE) C95. 1-1992.
safely participate in such activities. Always use technology safely. adjustments should be made only by or under the supervision of a person 3. Insert the three AA alkaline batteries with + and - polarity as shown activity on the current channel before you talk.
Institute of Electrical and Electronics Engineers (IEEE) C95.1-1999 certified as technically qualified to perform transmitter maintenance and
Do not place a portable radio in the area over an air bag or in the air inside.
Edition. repairs in the private land, mobile and fixed services as certified by an Push-to-Talk PTT Timeout Timer
bag deployment area. Air bags inflate with great force. If a portable 4. Reposition the battery cover and press down to secure.
International Commission on Non-Ionizing Radiation Protection organization representative of the user of those services. Replacement of To prevent accidental transmissions and save battery life, the radio
(ICNIRP) 1998. radio is placed in the air bag deployment area and the air bag inflates, any transmitter component (crystal, semiconductor, etc.) not authorized
Radio Battery Meter emits a continuous warning tone and stops transmitting if you press
the radio may be propelled with great force and cause serious injury to by the IC/FCC equipment authorization for this radio could violate IC/FCC PTT for 60 continuous seconds.
Ministry of Health (Canada) Safety Code 6. Limits of Human Exposure The radio battery icon shows the radio battery charge level, from full
to Radiofrequency Electromagnetic Fields in the Frequency Range occupants of the vehicle. rules.
to empty . When the radio has one segment left, the radio
from 3 KHz to 300 GHz, 1999. Note: Use of this radio outside the country where it was intended to be chirps periodically or after releasing PTT (Low Battery Alert).
Australian communications Authority Radiocommunications distributed is subject to government regulations and may be prohibited.
(Electromagnetic RadiationHuman Exposure) Standard, 2003.
Continued on back
MD Series
MD_Series_US.qxd:Layout 1 2/6/12 12:25 PM Page 2
PTT
PTT
Menu Options
PTT
Special Features
PTT
PTT
To avoid accidentally changing your radio settings you can lock your
Products and Accessories as One (1) year from the date of Normal Wear and Tear. Periodic maintenance, repair and
Your radio has 22 channels.PTTThe channel is the frequency your radio the United States and Canada.
keypad: defined above, unless otherwise purchase by the first consumer replacement of parts due to normal wear and tear are excluded from
uses to transmit. (See Channels and Frequencies table below.)
1. Press and hold until displays. provided for below. purchaser of the product unless coverage.
1. Briefly press and release . The channel number flashes. 2. When in lock mode, you can turn the radio on and off, receive, otherwise provided for below.
What Does this Warranty Cover? PTT
Batteries. Only batteries whose fully charged capacity falls below
2. Press or to select a channel. transmit, send a call tone, and monitor channels. All other functions Subject to the exclusions contained to the right,
PTT
Giant International 1. Consumer Two-Way Radio 1. Ninety (90) days from the 80% of their rated capacity and batteries that leak are covered by
3. Press PTT to confirm or to continue set up. are locked. Ltd. warrants the Motorola branded consumer two-way radios that Accessories. date of purchase by the first this limited warranty.
To unlock the radio, press and hold for a few seconds until no operate via Family Radio Service or General Mobile Radio Service consumer purchaser of the
longer displays. that it manufactures (Products) and the Motorola branded or Abuse & Misuse. Defects or damage that result from: (a) improper
Channels and Frequencies product.
certified accessories sold for use with thesePTT
Products that it operation, storage, misuse or abuse, accident or neglect, such as
Scanning Channels manufactures (Accessories) to be free from defects in materials 2. Products and Accessories 2. The balance of the original physical damage (cracks, scratches, etc.) to the surface of the
Use scan to search the 22 channels for transmissions from unknown
Line Drawing best fitting for UG
Frequency Frequency and workmanship under normal consumer usage for the period(s) that are Repaired or warranty or for ninety (90) product resulting from misuse; (b) contact with liquid, water, rain,
Channel Description Channel Description parties, to find someone in your group who has accidentally changed outlined below. This limited warranty is a consumers exclusive
(MHz) (MHz) channels, or to quickly find unused channels for your own use.
Replaced. days from the date returned extreme humidity or heavy perspiration, sand, dirt or the like, extreme
remedy, and applies as follows to new Motorola branded Products to the consumer, whichever heat, or food; (c) use of the Products or Accessories for commercial
1 462.5625 GMRS/FRS 12 467.6625 FRS To start Scanning: and Accessories manufactured by Giant International Ltd., and is longer. purposes or subjecting the Product or Accessory to abnormal usage
1. Briefly press the key. The scan will appear in the display, and the purchased by consumers in the United States and Canada, which or conditions; or (d) other acts which are not the fault of Motorola
2 462.5875 GMRS/FRS 13 467.6875 FRS radio will begin to scroll through the channel. are accompanied by this written warranty:
Date: Aug 26, 2011_Rev.1 Solutions, Inc. or Giant International Ltd., are excluded from coverage.
e Drawing best fitting for UG Model: MD200 2. When the radio detects channel activity matching the channel, it
3 462.6125 GMRS/FRS 14 Drawing
Description: Line 467.7125 FRS
with point lines stops scrolling and you can hear the transmission. Use of Non-Motorola branded Products and Accessories. Defects
Scale 1 : 1 for radio size or damage that result from the use of Non-Motorola branded or
Date: Aug
3. To respond and talk to the person transmitting, press within five
4 462.6375 GMRS/FRS 15 26, 2011_Rev.1
462.5500 GMRS certified Products, Accessories, or other peripheral equipment are
MENU Model: MD200 seconds after the end of the transmission.
Description: Line Drawing with point lines excluded from coverage.
5 462.6625 GMRS/FRS 16 462.5750 GMRS 4. The radio will resume scrolling through the channels five seconds
MENU Scale 1 : 1 for radio size
after the end of any received activity. Unauthorized Service or Modification. Defects or damages
6 462.6875 GMRS/FRS 17 462.6000 GMRS 5. To stop scanning, briefly press the key. resulting from service, testing, adjustment, installation,
Line Drawing best fitting for UG PTT maintenance, alteration, or modification in any way by someone
7 462.7125 GMRS/FRS 18 462.6250 GMRS Scanning Notes other than Motorola Solutions, Inc., Giant International Ltd. or its
1. If you press while the radio is scrolling through inactive authorized service centers, are excluded from coverage.
8 467.5625 FRS 19 462.6500 GMRS Line Drawing best fitting for UG
channels, the transmission will be on the home channel. Scanning
Date: Aug 26, 2011_Rev.1 will resume five seconds after the end of your transmission. You may Altered Products. Products or Accessories with (a) serial numbers
9 467.5875 Model:
FRS MD20020 462.6750 GMRS or date tags that have been removed, altered or obliterated; (b)
press the key to stop scanning at any time.
Description: Line Drawing with point lines
broken seals or that show evidence of tampering; (c) mismatched
Scale 1 : 1 for radio size 2. If the radio stops on an undesired transmission, you may
10 467.6125 FRS 21Date: Aug
462.7000
26, 2011_Rev.1
GMRS board serial numbers; or (d) nonconforming or non-Motorola
immediately resume the scan by briefly pressing or .
Model: MD200 branded housings, or parts, are excluded from coverage.
11 467.6375 FRS 22Description: Line Drawing
462.7250 with point lines
GMRS 3. If the radio repeatedly stops on an undesired transmission, you may
Scale 1 : 1 for radio size temporarily remove that channel from the scan list by pressing and Communication Services. Defects, damages, or the failure of
holding or for three seconds. You may remove more than one PTT Products or Accessories due to any communication service or
Setting and Transmitting Call Tones
PTT PTT channel in this way. signal you may subscribe to or use with the Products or Accessories
Your radio can transmit different call tones to other radios in your group
Date: Aug 26, 2011_Rev.1 Line Drawing best fitting for UG
soModel:
you can alert them that you want to talk. You have 10 call tones from 4. To restore the removed channel(s) to the scan list, turn the radio off is excluded from coverage.
MD200
which to choose.
Description: Line Drawing with point lines and then back on, or exit and re-enter the scanning mode by PTT
To Scale
set a call for radioDate:
1 : 1tone: size Aug 26, 2011_Rev.1
PTT pressing .
Model: MD200 Line Drawing best fitting for UG Who is covered? What Other Limitations Are There?
1. With the radio on,Description:
short pressLine until the with
Drawing appears. The current call
point lines 5. You cannot remove the home channel from the scan list. This warranty extends only to the first consumer purchaser, and is ANY IMPLIED WARRANTIES, INCLUDING WITHOUT LIMITATION
tone setting flashes.Scale 1 : 1 for radio size not transferable. THE IMPLIED WARRANTIES OF MERCHANTABILITY AND FITNESS
2. Press or to change and hear the call tone. Use With Accessories FOR A PARTICULAR PURPOSE, SHALL BE LIMITED TO THE
3. Press PTT to set the new call tone or to continue set up. You can transmit more reliably with the use of optional PTT headset What will GIANT INTERNATIONAL LTD. do? DURATION OF THIS LIMITED WARRANTY, OTHERWISE THE REPAIR,
To transmit your call tone to other radios set to the same channel as accessories. A PTT headset allows privacy to others around you while GIANT INTERNATIONAL LTD., at its option, will at no charge repair, REPLACEMENT, OR REFUND AS PROVIDED UNDER THIS EXPRESS
listening. Line Drawing best fitting for UG replace or refund the purchase price of any Products or
your radio, press . LIMITED WARRANTY IS THE EXCLUSIVE REMEDY OF THE
Many accessories (sold separately) are available for your radio. For Accessories that does not conform to this warranty. We may use CONSUMER, AND IS PROVIDED IN LIEU OF ALL OTHER
Note: Setting the call to 0 disables the call tone feature. Line Drawingorbest fitting for UG
more information, visit our Web site at www.motorolasolutions.com PTT functionally equivalent reconditioned/ refurbished/ pre-owned or WARRANTIES, EXPRESS OR IMPLIED. IN NO EVENT SHALL
PTT shop.giantintl.com. new Products, Accessories or parts.
Transmitting a Talk Confirmation ToneDate: Aug 26, 2011_Rev.1
MOTOROLA SOLUTIONS. INC. OR GIANT INTERNATIONAL LTD. BE
You can set your radio to transmit aModel: 1. Turn the radio off and plug the PTT accessory into the accessory LIABLE, WHETHER IN CONTRACT OR TORT (INCLUDING
uniqueMD200
tone when you finish How to Obtain Warranty Service or Other Information?
Description:
transmitting. It is like saying Roger or OverLine Drawing
to let otherswith
knowpoint
youlines jack. PTT
NEGLIGENCE) FOR DAMAGES IN EXCESS OF THE PURCHASE PRICE
Scale 1 : 1 forPTT
radio size 2. Turn the radio on. You may now press the PTT on the accessory To obtain service or information, please call:
are finished talking. OF THE PRODUCT OR ACCESSORY, OR FOR ANY INDIRECT,
microphone instead of the radio.
1. With the radio on, short press until appears. The current INCIDENTAL, SPECIAL OR CONSEQUENTIAL DAMAGES OF ANY
3. Adjust the volume appropriately by pressing . Lower the volume USA and Canada Two-Way Radios
setting On/Off flashes. KIND, OR LOSS OF REVENUE OR PROFITS, LOSS OF BUSINESS,
before placing the accessory on your head or in your ear. 1-800-638-5119 LOSS OF INFORMATION OR OTHER FINANCIAL LOSS ARISING OUT
2. Press or to turn On or Off.
3. Press PTT to set the talkAug
Date: confirmation tone or
26, 2011_Rev.1 to continue Note: The MD Series does not have VOX capabilities, and is only
PTT
giantintl@callcenter.com OF OR IN CONNECTION WITH THE ABILITY OR INABILITY TO USE
set up. PTT Model: MD200 compatible with PTT headset accessories. For Accessories, please call the telephone number designated THE PRODUCTS OR ACCESSORIES TO THE FULL EXTENT THESE
Description: Line Drawing with point lines Line Drawing best fitting for UG
above for the product with which they are used. DAMAGES MAY BE DISCLAIMED BY LAW.
Keypad Tones Scale 1 : 1 for radio size
MENU
PTT
PTT
You may enable or disable the speaker key tones. You will hear the key You will receive instructions on how to ship the Products or Some states and jurisdictions do not allow the limitation or exclusion
MENU
tone each time a button is pushed. Accessories at your expense, to a GIANT INTERNATIONAL LTD. of incidental or consequential damages, or limitation on the length of
1. Press until appears. The current setting On/Off will flash. Authorized Repair Center. To obtain service, you must include: (a) a an implied warranty, so the above limitations or exclusions may not
copy of your receipt, bill of sale or other comparable proof of apply to you. This warranty gives you specific legal rights, and you
2. Press either or to turn On or Off.
purchase; (b) a written description of the problem; (c) the name of may also have other rights that vary from state to state or from one
3. Press PTT to confirm or to continue set up.
Line Drawing best fitting for UG your service provider, if applicable; (d) the name and location of the jurisdiction to another.
Note: When the key tone feature is off, the following are not disabled:
Transmit timeout alert tone
installation facility (if applicable) and, most importantly; (e) your
Power-down alert tone
address and telephone number.
Low battery alert tone PTT
2. Press or to set the time to 30 minutes, 60 minutes or Motorola Trademark Holdings, LLC and are used under license. All
PTT
90 minutes. other trademarks are the property of their respective owners. 2012
3. When you exit the Menu mode, the setting timer will begin if you are Motorola Solutions, Inc. All rights reserved.
not using the radio. MENU
MENU
MENU
MD Series