Professional Documents
Culture Documents
Sim Alp2 Um PDF
Sim Alp2 Um PDF
SPECIFICATION DISCLAIMER
Current Output 4-20mA Two-Wire Device This device is intended to provide general
4-20mA Current Source assistance with current loop and analog input
Output Range 4mA to 20mA debugging, testing and application development.
Fixed Steps 1mA or 0.1mA increments It should not be permanently used in live
Output Accuracy 1% of full scale at 25C production systems.
Accordingly, production system must be tested
Load Range 0-500 Ohm
and commissioned with calibrated instruments to
Voltage Output 0-10 V Voltage Source ensure safe and reliable operation.
Output Range 0V to 10V
IN NO EVENT SHALL THE DEVICE
Fixed Steps 1V or 0.1V increments MANUFACTURER BE LIABLE FOR ANY DAMAGES
Output Accuracy 1% of full scale at 25C OF ANY KIND INCLUDING DIRECT, INDIRECT,
Minimum Load 20kOhm INCIDENTAL, CONSEQUENTIAL, LOSS OF PROFIT
Protection Reverse Polarity OR DAMAGE.
Over-current (El. Fuse) The examples and diagrams in this manual are
Open Wire (Current) included for illustrative purposes only. Because of
Excessive Loop Voltage the many variables and requirements associated
Output Short (Voltage) with any particular installation, the device
Power Supply manufacturer cannot assume responsibility or
liability for actual use based on the examples and
Internal Power Battery 2xAA
diagrams.
Ni-MH or Alkaline Before making any decision or taking any action
2-Wire Current 12-30V DC External Power that might affect your equipment, you should
Temperature range 0-50C consult a qualified professional advisor.
Important: This device is not a calibrator, it
can't be used for Input module, sensor or
instrument calibration.
Do Not Operate Device Unless Area Is
Non-Hazardous