Professional Documents
Culture Documents
Me Preboard MD Mar 2011 Set A
Me Preboard MD Mar 2011 Set A
22. The formula to find out the number of turn of the crank
simple indexing is
A. T=20/N C. T=N/20
B. T=40/N * D. T=N/40
23. In a standard dividing head the ratio between the worm
wheel and the worm is
A. 10:1 C. 20:1
D. 30:1 D. 40:1 *
28. All four compression coil spring support one load of 700
kg/mm. All four springs are arranged in parallel and rated
same at 0.609 kg/mm. Compute the deflection in mm.
A. 64 C. 178
B. 147 D. 287 *
32. Determine the length of belt needed for a two flat belt
pulleys having a diameter of 70 cm and 30 cm. The center
distance is 400 cm and pulleys rotate in same direction.
Assume power transmitted is 10 hp at 200 rpm.
A. 958 cm * C. 589 cm
B. 859 cm D. 895 cm
42. Mark the cutter which works simultaneously with up cut and
down cut process
A. Side milling cutter.
B. Semi-circular milling cutter.
C. Shell end mill. *
D. Plain milling cutter.
60. In the selection of wire rope, regular lay means wires and
strands are arranged in the following manner:
A. twisted in the same direction
B. twisted in opposite direction*
C. twisted in any direction
D. twisted in along direction
61. In involute teeth, the pressure angle is often defined as
the angle between the line of action and the line of
tangent to the pitch circle. It is also termed as-
A. helix angle C. Angle of obliquity *
B. angle of recess D. Arc of action
71. The use of hardened steel for the mating metal gear appears
to give the best results and longer operational life. The
usual hardness is in the range of-
A. over 600 BHN * C. below 350 BHN
B. 300 to 400 BHN D. over 400 BHN
72. Continuous stretching under load even if the stress is less
than the yield point
A. plasticity C. creep *
B. elasticity D. ductility
76. Find the torsional moment in N-m developed when the shaft
delivers 40.2 hp at 260 rpm.
A. 901 x 10 to the 3rd power C.1102 x 10 to the 2nd power
B. 901 x 10 to the 2nd power D.1102 x 10 to the 3rd power *
78. A pair of gear and pinion having a ratio of 4 with the gear
having 100 teeth and the pinion with 25 teeth. Find the
circular pitch, if the center distance is 15 and the pitch
is at 6.
A. 0.94 C. 0.610
B. 0.754 * D. 0.552
83. A bolt has a tensile load of 300 lbs. The bolt is made of
SAE 1040 material with Sy = 55 ksi, what is the stress area
of the bolt?
A. 0.1023 in2 * C. 0.327 in2
2
B. 0.1230 in D. 0.5190 in2
97. When preparing to tap a hole, the size of the drill will be
A. equal to the size of the tap
B. larger than the size of the tap
B. smaller than the size of the tap *
D. none of the above
98. When preparing to tap a hole for a pipe fitting the size of
the drill will be :
A. larger than the tap size *
B. smaller than the tap size
C. equal to the size of the tap
D. none of the above