Professional Documents
Culture Documents
IJETR021306
IJETR021306
IJETR021306
23 www.erpublication.org
A New Proposal Of MPPT In Grid Connected PV System Using Intelligent Fuzzy Based PSO For Customized Step-Up
Cuk Converter
Figure 1. Photovoltaic Panel I-V and P-V Characteristic curve Figure 2. Flowchart of a standard PSO
24 www.erpublication.org
International Journal of Engineering and Technical Research (IJETR)
ISSN: 2321-0869, Volume-2, Issue-3, March 2014
global best fitness values (Pbest,i and gbest) and positions as either 1 or 0, but the scheme can deal with them as simplified
necessary. fuzzy functions that happen to be either one value or another.
Step4. Updating velocity and position of each particle
In fuzzification process, the numerical input variables are
The velocity and position of each particle in the swarm is
changed to linguistic variables in accordance with the
updated using Eq. (4) and (5).
membership functions which are presented in Figure. 4.
Step5. Determination of Convergence
the convergence criterion is checked . If the convergence
criterion is met, the process can be terminated; otherwise, the
iteration number will increase by 1 and go to step 2.
a) Fuzzification
25 www.erpublication.org
A New Proposal Of MPPT In Grid Connected PV System Using Intelligent Fuzzy Based PSO For Customized Step-Up
Cuk Converter
E\CE NB NS ZO PS PB
NB NB NB NB NS ZO
ZO NB NS ZO PS PB
IV. CUSTOMIZED STEP-UP CUK CONVERTER
26 www.erpublication.org
International Journal of Engineering and Technical Research (IJETR)
ISSN: 2321-0869, Volume-2, Issue-3, March 2014
duty cycle
Figure 8. Simulation diagram of PV Panel
27 www.erpublication.org
A New Proposal Of MPPT In Grid Connected PV System Using Intelligent Fuzzy Based PSO For Customized Step-Up
Cuk Converter
power output with faster dynamic response and higher Table 2 shows the performance of the proposed Customized
accuracy irrespective of irradiation changes. Particularly, it step-up cuk converter with the conventional Boost Converter
can be noted that the oscillation are very much suppressed in at solar irradiation and temperature of 1000 W/ and 75
using Customized step-up cuk converter when to the usage degree Celsius.
of classical boost converter.
TABLE 2. PERFORMANCE ANALYSIS OF PROPOSED SYSTEM
REFERENCES
28 www.erpublication.org
International Journal of Engineering and Technical Research (IJETR)
ISSN: 2321-0869, Volume-2, Issue-3, March 2014
[2] Chia-Nan Ko and Chia-Ju Wu ,A PSO-Tuning Method for Design of
Fuzzy PID Controllers, Journal of Vibration and Control, March
2008; vol. 14, 3: pp. 375-395., first published on December 20, 2007
[3] Desai H P and Patel H k., "Maximum power point algorithm in PV
generation: an overview", in 7th International Conference on Power
Electronics and Drive Systems, Bangkok, 2007, pp. 624-630
[4] Esram T and Chapman P.L., Comparison of photovoltaic array
maximum power point tracking techniques, IEEE Trans. Energy
Convers., 2007,22, pp. 439449
[5] Fangrui Liu., Shanxu Duan., Fei Liu, Bangyin Liu., and Yong Kang.,
"A variable step size INC MPPT method for PV systems", IEEE
Trans. on Industrial Electronics, vol. 55, no. 7, pp.2622~2628, July
2008.
[6] Francisco M. Gonzlez-Longatt.,"Model of photovoltaic module in
Matlab", do congreso iberoamericano de estudiantes de
ingeniera elctrica, electrnica y computacin,ii cibelec 2005.
[7] Gopal Raj Murugananth and Subramanian Vijayan, Development of
fuzzy controlled chopper drive for permanent magnetic DC motor,
Journal of Vibration and Control, 1077546313490184, first
published on July 8, 2013
[8] Hong Li and Li-Qun Liu ,A novel particle swarm optimization
maximum power point tracking control method based on the direct
current voltage superposition principle under partially shaded
conditions,Journal of Vibration and
Control,1077546312471068, first published on April 10, 2013
[9] Ishaque K. and Salam Z.., A deterministic particle swarm
optimization maximum power point tracker for photovoltaic system
under partial shading condition, IEEE Trans. Ind. Electron., vol. 60,
no. 8, pp. 31953206,Aug. 2013.
[10] Jianjun Yao, Guilin Jiang, Shuang Gao, Han Yan, and Duotao Di,
"Particle swarm optimization-based neural network control for an
electro-hydraulic servo system", Journal of Vibration and
Control, 1077546312472926, first published on April 10, 2013.
[11] Kuo Y-C., Liang T-J., and Chen J-F.," Novel Maximum-
Power-Point-Tracking Controller For Photovoltaic Energy
Conversion System", IEEE Transactions On Industrial Electronics,
Vol. 48, No. 3, Pp. 594-601, 2001.
[12] Liqun Liu, Chunxia Liu, Jianan Wang, and Yigang
Kong,Simulation and hardware implementation of a hill-climbing
modified fuzzy-logic for maximum power point tracking with direct
control method using boost converter, Journal of Vibration and
Control, 1077546313486912, first published on July 3, 2013
[13] Martin Holladay., An Introduction to Photovoltaic Systems, GBA
Advisor, 2012.
[14] Masoum M.A.S. and Sarvi M., Design, Simulation and Construction
of a New Fuzzy-Based Maximum Power Point Tracker for
Photovoltaic Applications, in Proceedings of the Australasian
University Power System Engineering Conference (AUPEC '02),
2002
[15] Mummadi Veerachary., Tomonobu Senjyu., and Katsumi Uezato.,
Feedforward maximum power point tracking of PV systems using
fuzzy controller, IEEE transactions on Aerospace and Electronics
Systems, Vol. 38, Issue 3, 2002, pp. 969-981.
[16] Parsopoulos K. E. and Vrahatis M. N., "Particle Swarm Optimization
and Intelligence: Advances and Applications" , Igi Global, 2010
[17] Rong-Jong Wai., Wen-Hung Wang., and Chung-You Lin.,
"High-Performance Stand-Alone Photovoltaic Generation System",
IEEE Trans. on Industrial Electronics, vol. 55, no. 1, pp. 240-250,
Jan 2008.
[18] Saeed Farzi.," Training of Fuzzy Neural Networks via
Quantum-Behaved Particle Swarm Optimization and Rival Penalized
Competitive Learning", The International Arab Journal of
Information Technology, Vol. 9, No. 4, July 2012.
[19] Salas V., Olas E., Barrado A., and Lazaro A., "Review of the
maximum power point tracking algorithms for stand-alone
photovoltaics systems",Sol. Energy Mater. Sol. Cells, 2006, 90, pp.
15551578.
[20] Soundarrajan.A and Sumathi.S, "Fuzzy-based intelligent controller
for power generating systems, Journal of Vibration and
Control, July 2011; vol. 17, 8: pp. 1265-1278., first published
on November 8, 2010.
[21] Wei J., Yao K., Xu M., and F. C. Lee., Applying transformer concept
to nonisolated voltage regulators significantly improves the efficiency
and transient response, in Proc. IEEE Power Electron.
29 www.erpublication.org