Professional Documents
Culture Documents
How To Save From Non Dyanamic Current
How To Save From Non Dyanamic Current
How To Save From Non Dyanamic Current
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Wearing shoes with memory foam on the inside,
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Here are a few ideas for reducing static electricity:
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
Having flannel sheets on your bed, and
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Static electricity isn't all bad
A number of technologies that we take for granted depend on the use of static electricity,
including photocopiers, laser printers, automotive paints, and certain types of air filters.
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
Homemade grounding strip
At my desk I have found that touching my metal clamp-on swing-arm lamp is a convenient way
to discharge my static electricity before touching my computers. However, when I want to watch
the television shows I've recorded on my Tivo DVR, if I happen to touch the Tivo's case, in the
winter I often feel a static shock. Some of the time the shock makes the Tivo stop working;
luckily rebooting it has brought it back to life, but this motivated me to make my own simple
"touch-me-first" pad that combines:
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Wearing shoes with memory foam on the inside,
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Here are a few ideas for reducing static electricity:
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
Having flannel sheets on your bed, and
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Static electricity isn't all bad
A number of technologies that we take for granted depend on the use of static electricity,
including photocopiers, laser printers, automotive paints, and certain types of air filters.
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
Homemade grounding strip
At my desk I have found that touching my metal clamp-on swing-arm lamp is a convenient way
to discharge my static electricity before touching my computers. However, when I want to watch
the television shows I've recorded on my Tivo DVR, if I happen to touch the Tivo's case, in the
winter I often feel a static shock. Some of the time the shock makes the Tivo stop working;
luckily rebooting it has brought it back to life, but this motivated me to make my own simple
"touch-me-first" pad that combines:
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Wearing shoes with memory foam on the inside,
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Here are a few ideas for reducing static electricity:
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
Having flannel sheets on your bed, and
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Static electricity isn't all bad
A number of technologies that we take for granted depend on the use of static electricity,
including photocopiers, laser printers, automotive paints, and certain types of air filters.
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
Homemade grounding strip
At my desk I have found that touching my metal clamp-on swing-arm lamp is a convenient way
to discharge my static electricity before touching my computers. However, when I want to watch
the television shows I've recorded on my Tivo DVR, if I happen to touch the Tivo's case, in the
winter I often feel a static shock. Some of the time the shock makes the Tivo stop working;
luckily rebooting it has brought it back to life, but this motivated me to make my own simple
"touch-me-first" pad that combines:
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Wearing shoes with memory foam on the inside,
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Here are a few ideas for reducing static electricity:
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
Having flannel sheets on your bed, and
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Static electricity isn't all bad
A number of technologies that we take for granted depend on the use of static electricity,
including photocopiers, laser printers, automotive paints, and certain types of air filters.
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
Homemade grounding strip
At my desk I have found that touching my metal clamp-on swing-arm lamp is a convenient way
to discharge my static electricity before touching my computers. However, when I want to watch
the television shows I've recorded on my Tivo DVR, if I happen to touch the Tivo's case, in the
winter I often feel a static shock. Some of the time the shock makes the Tivo stop working;
luckily rebooting it has brought it back to life, but this motivated me to make my own simple
"touch-me-first" pad that combines:
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Wearing shoes with memory foam on the inside,
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Here are a few ideas for reducing static electricity:
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
Having flannel sheets on your bed, and
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Static electricity isn't all bad
A number of technologies that we take for granted depend on the use of static electricity,
including photocopiers, laser printers, automotive paints, and certain types of air filters.
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
Homemade grounding strip
At my desk I have found that touching my metal clamp-on swing-arm lamp is a convenient way
to discharge my static electricity before touching my computers. However, when I want to watch
the television shows I've recorded on my Tivo DVR, if I happen to touch the Tivo's case, in the
winter I often feel a static shock. Some of the time the shock makes the Tivo stop working;
luckily rebooting it has brought it back to life, but this motivated me to make my own simple
"touch-me-first" pad that combines:
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Wearing shoes with memory foam on the inside,
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Here are a few ideas for reducing static electricity:
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
Having flannel sheets on your bed, and
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Static electricity isn't all bad
A number of technologies that we take for granted depend on the use of static electricity,
including photocopiers, laser printers, automotive paints, and certain types of air filters.
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
Homemade grounding strip
At my desk I have found that touching my metal clamp-on swing-arm lamp is a convenient way
to discharge my static electricity before touching my computers. However, when I want to watch
the television shows I've recorded on my Tivo DVR, if I happen to touch the Tivo's case, in the
winter I often feel a static shock. Some of the time the shock makes the Tivo stop working;
luckily rebooting it has brought it back to life, but this motivated me to make my own simple
"touch-me-first" pad that combines:
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Wearing shoes with memory foam on the inside,
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Here are a few ideas for reducing static electricity:
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
Having flannel sheets on your bed, and
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Static electricity isn't all bad
A number of technologies that we take for granted depend on the use of static electricity,
including photocopiers, laser printers, automotive paints, and certain types of air filters.
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
Homemade grounding strip
At my desk I have found that touching my metal clamp-on swing-arm lamp is a convenient way
to discharge my static electricity before touching my computers. However, when I want to watch
the television shows I've recorded on my Tivo DVR, if I happen to touch the Tivo's case, in the
winter I often feel a static shock. Some of the time the shock makes the Tivo stop working;
luckily rebooting it has brought it back to life, but this motivated me to make my own simple
"touch-me-first" pad that combines:
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!
Has this ever happened to you? You walk across a rug, then touch a doorknob or light switch or
computer or another person and ZAP! You feel a spark on your fingertip, anywhere from a mild
flicker to a painful shock. Here is my advice on what you can do about this.
You run your hands across a coat or jacket made of fleece or wool or fur.
Static build-up is most likely to occur when the humidity is low, for example during the winter
when the air is dry and you may be indoors more than in the warmer weather. It will also depend
on the clothes and shoes you're wearing, and also on your body chemistry (i.e., how much your
body electrically acts like a capacitor).
In an informal and unscientific survey of friends and colleagues, I've also learned that:
Walking on a deck made from composite materials, or the rubberized floor in a dance
studio,
can cause a build-up of static electricity, depending on the person and the circumstances.
This build-up and discharge of static electricity that you experience is a miniature version of the
same mechanism that causes lightning and thunder.
However, when microcomputers became available for consumers to use in the 1980s, static
electricity was a major concern. "Touch-me-first" pads that connected to a nearby ground (like a
wall outlet or radiator) were common and important accessories. As you sat down to use your
Atari or Apple II or the computer you built from a kit, you would touch that pad first to discharge
any static charge you were carrying and avoid damaging your delicate (and expensive)
equipment.
These days, the shielding and grounding of computers has improved to the point where the need
for regular users to have "touch-me-first" pads has disappeared into history. When I walk across
my rug and touch my laptop computer, I sometimes do feel a static shock, but my computer has
never had a problem. However, technicians who take computers apart to fix or service them
definitely need to be careful about static electricity.
You may feel that giving your computer static shocks is a bad idea, regardless of the
improvements in computer design over the years.
You may have other electronic devices that might not have good protection from static
shocks, including printers, scanners, smartphones, tablets, televisions, stereo systems,
cable boxes, Tivos and DVRs, etc.
You may find that getting static shocks from touching doorknobs or light switches is
painful or annoying, and that giving them to other people (or pets) gets you into trouble.
Dry skin carries more static electricity. Use hand lotion to moisturize your skin.
The soles of your shoes may be insulators. Try shoes with different soles, or see whether
going barefoot (if possible) makes a difference.
Spray your carpet with an anti-static agent. Be sure to let it dry before walking around so
you don't slip and fall. Or, try removing your carpet altogether.
See "Where to go from here" for resources containing even more ideas.
Touch a metal object connected to an earth ground: A water faucet, water pipe, radiator,
the grounded screws in a wall outlet or light switch plate, the metal frame of a lamp or
appliance, etc.
Touch any other large metal object: A file cabinet, doorknob, metal table or chair, etc.
While probably not connected to an earth ground, it's very likely to have a different or
neutral charge compared to you, and will take yours.
Discharge your static electricity when getting out of your car, especially at a gas station
If you experience a static shock when getting out of your car, try this: After you've slid across the
seat and opened the door, touch a metal part of the car's door or frame with your bare hand right
before your feet touch the ground. You may not feel any spark, but doing this will probably
dissipate your excess charge.
This is important to do at the gas station, especially if you pump your own gas, to avoid causing
a spark near the pump and possibly igniting the gas fumes. Don't forget to discharge again if you
get back in your car and get out a second time!
Also, if you are going to fill a gas can or portable fuel container, avoid building up a dangerous
static charge by taking the container out of your car or truck and placing it on the ground,
keeping the nozzle in contact with the container the entire time you're filling it, and putting the
cap back on the container before moving away from it.
Instead of using your finger to touch, say, a doorknob, use a knuckle or elbow instead.
They're not as sensitive as fingertips.
Hold a small metal object in your hand, like a key or coin or thimble or screwdriver or
ring. Make sure you're holding the metal part (not any plastic handle) and then touch the
doorknob with that instead. The spark will occur at the tip of the metal object instead of
on your skin. Don't use a valuable ring, it might tarnish from the spark, and don't use your
cell phone.
A "grounding cord": Its 3-prong end plugs into a grounded wall outlet, its 6-foot wire
only connects to the ground prong, and the other end of the cord has a metal alligator
clip.
A metal ruler: I attached the grounding cord's alligator clip to one end.
I put this grounded ruler on the table in front of my Tivo. Now that I always touch the ruler first
to discharge any static I've built up, I haven't shocked my Tivo since!