Professional Documents
Culture Documents
Sansico Electro Fussion Fitting With HDPE Pipe
Sansico Electro Fussion Fitting With HDPE Pipe
Material of pipes for cold water supply shall be of High Density Polyethylene
(HDPE) manufactured in compliant with MS 1058.
Material of fittings for cold water supply shall be of High Density Polyethylene
(HDPE) manufactured in compliant with BS EN 12201-3:2003.
1. Clean pipe ends to remove dirt, mud, and other debris from pipe ends.
2. Ensure that the pipe end has a square and even cut as close to 90
degree as possible.
4. Scrape the outside of the pipe surface to remove oxidation and other
contaminants. Do not use sandpaper.
5. Do not touch the scraped pipe surface or the inside of the coupler as
body oils and other contaminates will compromise fusion joint performance.
6. Install coupler onto the pipe ends, the stab depth marks are aligned at
the outer edges of the coupler.
C) Manufacturers Requirements
Contractor shall use HDPE pipe PN12.5 compliant with SIRIM standard MS
1058.