Professional Documents
Culture Documents
SAE - Dimension PDF
SAE - Dimension PDF
* 6" through 8" shaft has 1 inch per foot taper, " per inch taper. Angle with centerline is 2 23' 9". MARINE PROPELLERS HUB BORE DIMENSIONS
a Keyway shall be cut parallel to taper. Taper: Per Foot = "
b Fillets are recommended for keyways in shafts through 2" in diameter. fillets are mandatory for shafts Per Inch - " Angle with centerline = 1 47' 24"
above 2" in diameter. Dia. Small End Keyway Width Keyway Side Depth
c Threads are Unified and American Standard, Class 3A..
A C D
d Nuts are to be semi-finished stock, American Standard B18.2. Std.
e The shaft sleeve shown is recommended practice, but the use of a sleeve is optional.
Taper Min. Max. Nom. Min. Max. Nom. Min. Max.
0.608 0.610 0.1865 0.1875 0.098 0.100
0.710 0.712 0.249 0.250 0.129 0.131
1 0.812 0.814 0.249 0.250 0.129 0.131
1 0.913 0.915 0.249 0.250 0.129 0.131
1 1.015 1.017 0.3115 0.3125 0.162 0.165
1 1.116 1.118 0.3115 0.3125 0.161 0.164
1 1.218 1.220 0.374 0.375 0.195 0.198
HUB
1 1.421 1.423 0.4365 0.4375 0.226 0.229
2 1.624 1.626 0.499 0.500 0.259 0.262
2 1.827 1.829 0.561 0.5625 0.291 0.294 P R O P E L L E R B O R I N G
2 2.030 2.032 0.6235 0.625 0.322 0.325
2 2.233 2.235 0.6235 0.625 0.322 0.325
3 2.437 2.439 0.7485 0.750 0.323 0.326
To insure retention of inherent factory accuracy,
3 2.640 2.642 0.7485 0.750 0.323 0.326 order your propeller factory-bored whenever pos-
3 2.843 2.845 0.8735 0.875 0.324 0.327
3 3.046 3.048 0.8735 0.875 0.324 0.327 sible. When bored in the field, propellers should
4 3.249 3.251 1 0.9985 1.000 0.326 0.329 be bored to the pilot hole, NOT to the hub or
4 3.796 3.798 1 1.123 1.125 0.388 0.391
5 4.218 4.220 1 1.248 1.250 0.450 0.453 blade edges.
5 4.640 4.642 1 1.248 1.250 0.450 0.453
MARINE PROPELLER SHAFT END DIMENSIONS