Professional Documents
Culture Documents
VX-410 420 VHF SM Usa Ec050n90j
VX-410 420 VHF SM Usa Ec050n90j
Service Manual
Introduction
This manual provides technical information necessary
for servicing the VX-410/-420 series VHF FM Transceiver.
Servicing this equipment requires expertise in handling
surface-mount chip components. Attempts by non-qualified
persons to service this equipment may result in permanent
damage not covered by the warranty, and may be illegal in
some countries.
Two PCB layout diagrams are provided for each double-
sided circuit board in the transceiver. Each side of is re-
ferred to by the type of the majority of components installed
on that side (leaded or chip-only). In most cases one
side has only chip components, and the other has either a
mixture of both chip and leaded components (trimmers, coils,
electrolytic capacitors, ICs, etc.), or leaded components only.
While we believe the technical information in this man-
ual to be correct, VERTEX STANDARD assumes no liabil-
ity for damage that may occur as a result of typographical or
other errors that may be present. Your cooperation in point-
VX-410 series VX-420 series ing out any inconsistencies in the technical information
would be appreciated.
Important Note
After Lot.36 of this transceiver was assembled using Pb (lead) free solder, based on the RoHS specification.
Only lead-free solder (Alloy Composition: Sn-3.0Ag-0.5Cu) should be used for repairs performed on this apparatus.
The solder stated above utilizes the alloy composition required for compliance with the lead-free specification, and
any solder with the above alloy composition may be used.
Contents
Specifications .................................................................. 2 Board Unit (Schematics & Layouts)
Exploded View & Miscellaneous Parts ..................... 3 MAIN Unit ............................................................... 12
Parts List........................................................................... 4 DUMMY Unit .......................................................... 30
Block Diagram ................................................................ 5 Optional Units (Schematics & Layouts)
Circuit Description ........................................................ 6 FVP-25 Encryption / DTMF Pager Unit .............. 31
Alignment ........................................................................ 9 VTP-50 VX-Trunk Unit .......................................... 32
DVS-5 Voice Storage Unit ..................................... 33
Measurements per EIA standards unless noted above. Specifications subject to change without notice or obligation.
RA0173500
CAP
R6147510
RING NUT (x 2 pcs)
CP8477002
RA054610A FRONT CASE ASSY
KNOB ASSY (CH) (W/ LIGHT GUIDE,NAME PLATE,SP NET,SPEAKER,
PACKING PAD,PTT KNOB,SHEET(MIC))
RA054640A
VOLUME KNOB
RA054540A
RUBBER PTT
RA0210600
RUBBER PACKING
(x 2 pcs)
RA0545600
CR SPONGE RUBBER (VX-420)
RA0546600 RA0546500
LCD HOLDER (VX-420) RUBBER KNOB
(VX-420)
G6090204
LCD (VX-420) RA0546800
INTER CONNECTOR
RA0546700 (VX-420) CAUTION
LIGHT GUIDE (VX-420)
RA062960A
RA0546900 SPACER(MIC)
REFLECTOR SHEET (VX-420)
M3290056
MIC (W/ HOLDER RUBBER)
MAIN Unit
correct incorrect
RA0546000
RA010700A RUBBER PACKING
TERMINAL PLATE (+)
RA055770C
RA010340B LATCH NAIL
TERMINAL HOLDER
CP8427002
RA035160A CP8427003 (IS Type)
TERMINAL PLATE (-) REAR CASE ASSY
(w/SMA CONNECTOR,
TERMINAL PLATE (-),
PAN HEAD SCREW M2X3NI)
DUMMY Unit
RA037690B
SHEET
NAME PLATE
Non-designated parts are available only as part of a designated
assembly.
Frequency
Counter
Wide:0V
Narrow:0V
4.78V Wide:3.39V
4.42V 1.70V Narrow:0V
0.75V
0.51V 0.73V
0V
4.84V
Wide:0V
Narrow:0V
4.97V
2.45V (0.0V) (0V)
0.16V 0.78V (0.79V) 3.35V (4.11V)
(2.50V)
0.30V 0V (0V)
<1.07V> 0.16V 0.16V
{0.44V} (4.67V) 1.69V (4.95V)
0.16V
(0.83V) (1.74V)
0.48V
(2.88V) Wide:0.36V
3.46V Narrow:0.55V
(3.52V) Wide:3.67V Wide:0.84V
Narrow:3.67V Narrow:0V
3.96V
(3.78V)
0.3V 0.14V
0V <1.07V> 3.99V (2.86V)
<1.71V> {0.43V} 4.97V (4.10V)
{0.95V} (5.00V) 4.91V
0V 7.49V 2.39V
<2.52V> <7.33V> (0.0V)
(2.06V)
{2.01V} {7.40V} Wide:0V
0.02V Narrow:1.05V
7.49V <7.29V> {7.32V} Wide:0.36V
(0.46V) Narrow:0.55V Wide:0V Wide:3.39V
Narrow:1.06V Narrow:0V
2.82V 3.30V
6.47V (2.67V) (3.30V)
<6.51V>
{6.47V} 4.69V
0.98V <1.74V> {1.12V} (4.79V)
3.53V
(3.53V)
Wide:0V
Narrow:3.03V
2.95V (2.95V) 0.02V (3.46V)
7.48V (7.48V)
3.59V
(3.59V)
3.59V
3.51V 3.56V (3.59V)
(3.51V) (3.56V)
3.30V
3.59V 7.48V 3.59V 7.49V (3.30V)
[3.50V] [7.48V] [3.59V] [7.49V]
3.59V
(3.59V)
3.58V
[3.54V]
3.45V 7.49V
3.33V [3.45V] [7.48V]
[2.84V]
3.59V
(3.36V) 2.03V
[0.95V]
2.13V [1.05V]
0V
[2.93V]
3.35V
(3.35V) 0V
[2.93V]
2.72V
(2.72V)
3.51V (3.51V)
3.58V
(3.58V)
1.82V (1.82V)
3.54V
1.80V (3.54V) 1.67V
(1.77V)
3.51V
(3.51V)
0.15V
(4.96V)
SQL open : 0.60V 7.48V (7.48V) 4.97V
SQL close : 0.18V SQL open:6.73V 7.48V (5.01V)
SQL close:7.49V (7.48V)
0.0V
(0.0V) 3.59V
(3.59V) 3.57V (3.57V)
SQL open : 7.49V 0.0V (5.01V)
SQL close : 0.18V 3.58V (3.58V)
6.82V
(6.86V)
RX : XX
TX : (XX)
TX HIGH : <XX>
TX LOW : {XX}
LED on : [XX]
A B C D E
a b c d e
A B C D E
a b c d e
A B C D E
a b c d e
A B C D E
a b c d e
A B C D E
a b c d e
A B C D E
a b c d e
Parts Layout
Parts Layout
Side A Side B
Parts Layout
Side A Side B
Parts Layout
Side A Side B