Professional Documents
Culture Documents
Kathon Lxe (Pengawet in Can)
Kathon Lxe (Pengawet in Can)
KATHON LXE BIOCIDE In-can preservation for paints and other technical products
Description
KATHON LXE Biocide is an active ingredient preparation to preserve paints, binder dispersions and other technical
products.
KATHON LXE contains active substances permitted by the BfR and FDA for use in their application field, provided
that the customary dosage rates are not exceeded.
KATHON LXE may be employed in products to be used in close proximity to food, but not in immediate contact.
Composition: Chloromethylisothiazolinone/methylisothiazolinone
Typical Properties
Miscibility/Solubility
Forms clear solutions in all proportions with water, low alcohols, glycols, and glycol ethers.
Compatibility
KATHON LXE is compatible with most common binders. It is generally advisable to check compatibility prior to any
application to a special case.
Stability
Temperature: up to 40C (short period to 60C)
pH range: 4 to 9
KATHON LXE is a wet state preservative with a very wide application field such as paints, plasters, adhesives, inks,
dispersion and emulsion binders and aqueous technical products in general. It can be used alone or in combination
with other active ingredients such as e.g. methylisothiazolone (KORDEK MLX) or formaldehyde donors.
KATHON LXE is a proven slimicide in paper manufacturing. KATHON LXE contains neither formaldehyde nor
cationic or phenolic substances. Therefore, it is particularly suited for use in products not compatible with these
substances.
KATHON LXE has a broad spectrum of activity. It is effective against gram-positive and gram-negative, aerobic
and anaerobic bacteria as well as against mould and yeast.
KATHON LXE complies with several food contact legislations of the European Union and of the Food and Drug
Administration (FDA) of the USA.
For specific information please ask your local Rohm and Haas contact or liaise with our Product Integrity
Department.
The number of technical products being preserved with KATHON LXE is increasing steadily and it is not always
possible to predict its suitability. The optimum use should be established by a preliminary experiment. In critical
cases, predilution with water is often helpful.
Dosage
The optimum dosage rate of KATHON LXE depends upon the degree of contamination and the susceptibility of the
product to be preserved.
Occasionally, the degree of contamination exhibits seasonal fluctuation, so that a periodical determination of germ
counts can assist in choosing the optimum dosage rate.
Therefore, the ranges of concentrations listed below should be taken as general guidelines only:
In the case of special application, please consult either our Technical or our Biological Laboratories for assistance.
Handling
Please refer to the safety data sheet of this product for precise handling instructions.
The processing and use of industrial chemicals require adequate technical and professional knowledge.
In general, avoid eye and skin contact, wear safety goggles, gloves and protective clothing. In case of eye or skin
contact despite precautionary measures, wash immediately and thoroughly with plenty of warm water and obtain
medical attention.
The legal requirements prevailing in your country, especially on working hygiene and in the avoidance of
accidents, must be observed.
Storage
KATHON LXE Biocide should be stored in closed original containers in a cool place, but not below 0C. At
temperatures below 0C solidification of the product may occur. If the product does freeze, allow it to return to
room temperature and it will turn liquid again. Bioactivity is unaffected by freezing and melting.
Use biocides safely. Always read the label and product information before use.
KATHON is a trademark of Rohm and Haas Company, or of its subsidiaries or affiliates. The Companys policy is to register its
trademarks, where products designated thereby are marketed by the Company, its subsidiaries or affiliates.
These suggestions and data are based on information we believe to be reliable. They are offered in good faith, but without guarantee, as
conditions and methods of use of our products are beyond our control.
We recommend that the prospective user determines the suitability of our materials and suggestions before adopting them on a commercial
scale.
Suggestions for use of our products, or the inclusion of descriptive material from patents and the citation of specific patents in this publication,
should not be understood as recommending the use of our products in violation of any patents or as permission or license to use any patent of
the Rohm and Haas Company.
For further details, please contact your local Account Manager or local Business Representative.
Rohm and Haas, 2007 All rights reserved. BIO.KATHON LXE Biocide.PDS.E.04/2007