Professional Documents
Culture Documents
Bling Ring English PDF
Bling Ring English PDF
English Version
2
Supplies
6 Bicones 4mm
6 drop beads 3,4mm
1g seed beads size 11
1g Seed beads size 15
1g cylinder beads size 11
thread: Fireline 6lb test
beading needle size 12
Introduction
For one Ring you need about 3 ft of thread. In the first two rounds, you
should not have a too high tension, other wiese it is hard to make the
increases later.
Step 1
String 36 size 15 and make a ring by weaving again through the first
bead strung. Leave a tail of about 6 inch, you should be able to hold the
tail for creating the right counter tension while beading.
Step 3
String 1 cylinder bead and weave through the next sticking up size 15 of
the previous row. Repeat another 17 times and exit from the first cylin-
der bead added in this step.
Step 5
Add one cylinder bead in the first gap and each one size 11 in the follo-
wing two gaps. Repeat another 5 times to complete the circuit and exit
from the first cylinder bead added in this row.
Step 7
Weave through the following 4 size 11 of the previous rows. String one
drop bead and weave through the following size 11. Repeat another
5 times to complete the circuit. At the end weave back to the beads of
the first row and exit from a sticking up bead here (pointed line in the
drawing).
Step 9
Like step 4. Add each one cylinder bead in the first two gaps and one
size 11 in the next. Repeat another 5 times to complete the circuit and
exit from the first cylinder bead added in this row. Attention: You have
to choose your starting point carefully, the size 11 have to be in the
same position like they are in row #4 (see drawing).
Step 11
Like step 6. String 1 size 11, weave through the following 3 size 11s of
the previous rows. String one size 11 and weave through the following
cylinder bead. Repeat another 5 times to complete the circuit and exit
from the first size 11 added in this row.
Step 12
String 3 size 15, skip
the drop bead and
weave through the
following 5 beads (2 size
11, bicone, 2 size 11).
Repeat another 5 times
to complete the step.
Step 14
Repeat step 13 on the other
side of the ring. Then secure
the thread and the tail and
cut it off.
Sabine Lippert
!"$#$#"##!"%!&