Professional Documents
Culture Documents
Electrical Thermal Power Generation MCQ's
Electrical Thermal Power Generation MCQ's
3. On which one of the following cycles does a modern steam power plant work?
A. Otto cycle.
B. Carnot cycle.
C. Rankine cycle.
D. Bell - Coleman cycle.
12.In a thermal power plants, pressure in the working fluid cycle is developed by
A. condenser.
B. turbine.
C. superheater.
D. feed water pump.
18.In a steam power plant, the feed water coming to the economizer is heated
plant the feed water coming to the economizer is heated using
A. HP steam.
B. flue gas.
C. LP steam.
D. direct heat in the furnace.
30.Pulverized coal is
A. coal free from ash.
B. non smoking coal.
C. coal which burns for long time.
D. coal broken in fine particles.
31.Coking cokes
A. burn freely.
B. burn completely.
C. do not from ash.
D. from lumps or masses of coke.
33.In a thermal power plant, coal is carried from storage to boiler generally be
means of
A. V belt.
B. buckets.
C. manually.
D. trolleys.
41.The selection of the type and size of a steam boiler depends upon
A. the fuel and water availability.
B. the power required and working pressure.
C. the geographical position of power house.
D. all of above factors.
42.For given power a water tube boiler occupies
A. less floor area and more height.
B. less floor and less height.
C. more floor area and less height.
D. more floor area and more height than a fire tube boiler.
44.A super critical boiler is one that operates above the pressure and
temperature of following values
A. 100 Kg/cm2 and 540 C.
B. 100 Kg/cm2 and 373 C.
C. 218 Kg/cm2 and 373 C.
D. 200 atm and 550 C.
47.In a boiler, the carry over of slugs of water into the piping because of dirty
water is called the
A. pitting.
B. foaming.
C. beating.
D. scalping.
48.The efficiency of a boiler used in a modern steam power plant is of the order
of
A. 100 %.
B. 85 %.
C. 50 %.
D. 30 %.
49.Which of the following is not a fire tube boiler?
A. Babcock and Wilcox.
B. Cochrn.
C. Locomotive.
D. Lancashire.
53.In a steam power plant heat from the flue gases is recovered in
A. a chimney.
B. economizer and air preheater.
C. a condenser.
D. a desuperheater.
58.Any leakage of air into the condenser destroy the vacuum and causes
A. lowering of the partial pressure of the steam and of the saturation
temperature along with it.
B. an increase in air pressure in the condenser limiting the useful heat drop
in the steam turbine.
C. under cooling of the condensate more severe.
D. all of above.
65.In which part of the thermal power plant, the steam pressure is less than that
of atmosphere
A. turbine.
B. condenser.
C. boiler.
D. super heater.
73.Spray ponds are used for cooling warm water coming put of condenser in
A. small power plant.
B. medium power plant.
C. large power plant.
D. both (B) and (C).
80.In which of the following steam turbines the back pressure will below the
atmospheric one?
A. Topping turbine.
B. Back pressure turbine.
C. Condensing turbine.
D. None of these.