Professional Documents
Culture Documents
Sylhet Gas Field QS 2017
Sylhet Gas Field QS 2017
Sylhet Gas Field QS 2017
1. An artesian aquifer 10m thick with pizometric surface 40m above the bottom confining layer
is being pumped by a fully penetrating well. The aquifer is a medium sand (hydraulic
conductivity 1.5*10-4 m/s). Steady state draw downs of 5.00m and 1.00m are observed at two
non-pumping wells located 20.0m and 200.0m, respectively, from the pumped well. Determine
the discharge at the pumped well in m3/s.
2. The trapezoidal channel shown has a mannings co-efficient of n=0.013 and is laid at a slope
of 0.002. The depth of flow is 2.0 ft. what is the flow rate at ft3/s?
3. Laboratory analysis of water sample. All concentrations are as substance. Ca++=74 mg/l,
Mg=18.3 mg/l, Na=27.6 mg/l, K=39.1 mg/l, pH=7.8; HCO3-=274.5 mg/l, SO4=72 mg/l,
Cl=49.7 mg/l. Determine 1) Hardness of water in mg/l of CaCO3? 2) Amount of lime needed to
remove hardness by CaHCO3?
4. Find the resultant force on one side of a 25 cm diameter vertical circular plate standing at the
bottom of 3 m pool of water? (Density of water= 1000 kg/m3, g=9.81 m/s2)
5. True/false
1) TVF test gives a measure of the resistance of aggregate of crushing for weak aggregate.
6. Draw the typical fundamental diagram (speed vs density, flow vs density, speed vs flow) of
traffic flow.
8. 25% of a total sand sample is retained on each of 0.60 mm, 0.425 mm, 0.30 mm and 0.15 mm
sieves. Find the FM of sand sample.
9. If ground is level across an embankment width, determine the volume of earthwork. Given,
RL of FL 18 ft, width of FL=25 ft, side slope=2.5H:1V. RL of centerline of GL at chainage 0 ft,
80 ft and 200 ft are 21 ft, 18 ft and 16 ft respectively.
Engr. Sajedur Rahman Mishuk
themishuk@gmail.com
facebook.com/TheMishuk
11. Water content of a standard soil sample is 50%, specific gravity of soil solid (Gs)=2.65. Find
the values of bulk unit weight, dry unit weight and void ratio?
12. A sample of dry sand was tested in direct shear apparatus under a normal load of 36 kg. The
sample failed under a shearing load of 58 lb. the sample size was 2inch*2inch. What is the angle
of internal friction?
13. Compute consolidation settlement of a 2.5 m thick clay layer due to an increase of 30 KN/m2
pressure at the mid height of the layer. If vertical stress at the mid height of layer is 40 KN/m2.
Given, initial void ratio (e0)=0.7 and compression index (Cc)=0.25
14. A nine pile group constituting of 18 inch diameter concrete pile was cast in situ in a soil
whose unconfined compressive strength is 1000 lb/ft2. Each pile is 60 ft long. Using a reduction
factor =0.5 and factor of safety is 3. Calculate allowable skin friction of single pile.
16. A 100 mm by 100 mm beam is subjected to bending moment of 1 KN-m and 2 KN-m
applied about bone principal axis. Find maximum bending stress.
17. A bending moment of M1 is applied at the free end of a cantilever beam of length L of
continuous flexural rigidity EI. Find the equation of the elastic curve.