The document provides instructions for operating a rescue boat davit in either auto or manual mode. In auto mode, switches and a remote control are used to swing and hoist or lower the davit. In manual mode, valves are adjusted and handles are used to manually swing and raise or lower the davit and rescue boat hook. Safety procedures like securing equipment and switching off breakers are described.
The document provides instructions for operating a rescue boat davit in either auto or manual mode. In auto mode, switches and a remote control are used to swing and hoist or lower the davit. In manual mode, valves are adjusted and handles are used to manually swing and raise or lower the davit and rescue boat hook. Safety procedures like securing equipment and switching off breakers are described.
The document provides instructions for operating a rescue boat davit in either auto or manual mode. In auto mode, switches and a remote control are used to swing and hoist or lower the davit. In manual mode, valves are adjusted and handles are used to manually swing and raise or lower the davit and rescue boat hook. Safety procedures like securing equipment and switching off breakers are described.
DAVIT AUTO MODE USING REMOTE CONTROL: 1) Before using the Davit ensure that the BREAKER on EMERGENCY SWITCH BOARD inside emergency Gen room for the Rescue boat davit is turned on. 2) Open the junction box near Davit, switch on the BREAKER No #1 (Hydraulic motor), No #2 (Hoisting Motor) & No#3 (Remote control). 3) Close the junction box and PUSH the START button. 4) Ensure the Valve No# 1 is on AUTO Position. 5) Adjust the Valve No #2 on the marked position to SWING the davit to PORT/STBD. 6) Use the DAVIT REMOTE to SWING the davit and HOIST or LOWER the Wire. 7) After finishing the Operation Secure the Davit HOOK, Push STOP button & Switch of the Breaker NO# 1, 2 & 3 & Breaker on Emergency Switch board.
MANUAL MODE USING:
1)Ensure the Valve No# 1 is set on Manual position 2) Adjust the Valve No#2 on the MARKED POSITION to SWING the davit to PORT/STBD. 3) Once the valve No #2 is set to DESIRED POSITION, use the HANDLE with the HYDRAULIC PUMP to SWING the Davit. 4) The Hook can be lowered by RELEASING the BRAKE when Davit ON LOAD. 5) Use the HANDLE Located behind the brake to LOWER/HOIST the hook manually.