Professional Documents
Culture Documents
Calcium Grease Msds
Calcium Grease Msds
Calcium Grease Msds
roryr ir5pflt
General Trading Co. (L.L.C.)
\s,.r,orrr .&0.56-ol ntlo;l ?ill
LEADERS IN LUBRICANT
PAGE 1
SECTION I IDENTIFICATION
Product Name:
HEALTH HAZARDS:
INHALATION: Excessive rm-hal_ation of vapors or mists may cause upper respiratory tract irritation
and
central nervoussystem effects including headache, dizziness and nausea. nreathing
high concentrations of
oil mists may cause lipid
Pneumonia.
SKIN CONTACT: Prolonged or repeated contact may cause mild irritation or dryness.
I Tel'. +971 4 228 95 22 | Fax: +971 4 228 96 22 | P.O.Box: 34127 | Dubai, United Arab Emirates
MuslAB AL Gloo.tn plr oll Uono etspfii
General Trading Co. (L.L.C.) o tloll i
.,0.,0.56-al ? n
LEADERS IN LUBRICANT
l
PAGE-2
CHRONIC EFFECTS OF OVEREXPOSIIRE: Repeated skin contact may cause dermatitis. Used motor
oils havebeen found to cause skin cancer in skin painting studies with laboratory animals.
CARCINOGENICITY: None of the components of'this product are listed as a carcinogen or suspected
carcinogen byIARC, NTP or OSHA.
EYE CONTACT: Immediately flush eye with water for at least 15 minutes while lifting the upper and
lower lids. Getmedical attention.
,
SKIN CONTACT: Wash thoroughly with soap and water. Reinove contaminated clothing and launder
before reuse.Get medical attention if initation develops.
INHALATION: Remove victim to fresh air. If breathing has stopped give artificial respiration. If
breathing is difficulthave qualified personnel administer oxygen. Get medical attention.
INGESTION: Do not induce vomiting. Get immediate medical attention by calling a Poison Control
Center or hospitalemergency departrnent.
METIIOD: COC
EXTINGIIISHING MEDIA: Water spray or fog, foam, carbon dioxide, dry chemical.
SPECIAL FIREFIGHTING PROCEDURES: Firefighters should wear full emergency equipment and
NIOSH approvedpositive pressure self-contained breathing apparatus. Cool exposed intact containers with
water spray or stream.
UIIUSUAL FIRE AND EXPLOSION HAZARDS: At elevated temperatures containers may rupflre.
Use of largeamount of water may cause product to float and spread fire.
a) #
I Tel:+971 422895221 Fax:+971 4
.1 .a^
34127 | Dubai, United Arab Emirates
MusnAB AL Gloonn plr oll Unnn A5plJ
n tl0ll i
General Trading Co. (L.L.C.) \s_.,,0rr1 .,0.,0.5(t-ol ! n
LEADERS IN LUBRICANT
PAGE-3
VENTILATION: Good general room ventilation (equivalent to outdoors) should be adequate under
normal conditions.If the recommended exposure limit is exceeded increased mechanical ventilation such as
GLOVES: Rubber, neoprene or other impervious gloves are recommended where prolonged or repeated
skincontact is likely.
OTHER PROTECTM EQUIPMENT: Impervious apron, boots and other clothing are recommended if
needed toavoid prolonged/repeated skin contact. Suitable washing facilities should be available.
SECTION 9 PHYSICAL and CHEMICAL PROPERTIES
BOILING POINT (@760 mmHg) : >660oF MELTING POINT: Not available
APPEARANCE AND ODOR: Light amber to brown liquid, mild pefioleum odor.
SECTION r0 STABILITY and REACTMTY
PAGE-4
TOXIC SUBSTANCES CONTROL ACT: All of the components ofthis product are listed onthe TSCA
inventory.
CALIFORNIA PROPOSITION 65: This product is not known to contain any chemicals which are
known to the State
Of California to cause cancer or reproductive harm.
Canada: All of the components of this product are listed on the Canadian Domestic Substances List (DSL).
Australia: All ofthe ingredients of this product are listed on the Australian Inventory of Chemical
#is
Substances
EEC EINECS: All of the ingredients are listed on the EINECS inventory.
I Tel: +971 422895221 Fax: +971 422896 22 | P.O.Box: 34127 | Dubai, United Arab Emirates