Professional Documents
Culture Documents
IMOA Shop Sheet 104
IMOA Shop Sheet 104
1
Shop sheet 104
Table 2: Examples of weld joint designs used with duplex stainless steels
GTAW 35 13
t
GMAW 36 13
d SMAW 34 13
SMAW 4 15 13 12 55 65
GTAW 38 13 12 60 70
t
GMAW 5 12 13 12 60 70
d SAW 9 12 0 5 80
SMAW >10 1.5 3 13 55 65
SAW >10 0 35 90
d
SMAW > 25 13 13 10 15
r
k t GMAW > 25 13 13 10 15
SAW > 25 0 35 10 15
d
GTAW >3 02
t GMAW >3 02
d SMAW >3 02
SMAW 3 15 23 12 60 70
t GTAW 2.5 8 23 12 60 70
GMAW 3 12 23 12 60 70
d SAW 4 12 23 12 70 80
SMAW 12 60 12 23 10 15
GTAW >8 12 12 10 15
r
t
GMAW >12 12 23 10 15
d SAW >10 12 13 10 15
Source: ArcelorMittal
The International Molybdenum Association (IMOA) has made every effort to ensure that the information presented is technically correct. However, IMOA does not represent or warrant the accuracy of the information contained in this shop
sheet or its suitability for any general or specific use. The reader is advised that the material contained herein is for information purposes only; it should not be used or relied upon for any specific or general application without first obtaining
competent advice. IMOA, its members, staff and consultants specifically disclaim any and all responsibility of any kind for loss damage, or injury resulting from the use of the information contained in this publication.
Excerpt from Practical Guidelines for the Fabrication of Duplex Stainless Steels Second Edition 2009. Produced by IMOA. 07/14 2