Mamamki Instructions

You might also like

Download as docx, pdf, or txt
Download as docx, pdf, or txt
You are on page 1of 1

Mamamki Instructions

1. Ensure Rollers are in Correct Positions Under the White.


2. Ensure Outside Rollers are Outside Register Marks
3. Align Register Marks with Plotting Machine Groove to Ensure Material
is Straight. (If Needed, use White Sticker Marks to Align Material with
Grooves)
4. Lock Material in Place by Pushing the Lever Backward
5. Press End for a Sheet of Material, or Left Arrow for a Roll of Vinyl
6. Align Red Dot with Corner of Register Mark, then Press Enter
7. Change Depth, and Speed Settings by pressing the Tool Button. Use
the Left and Right Arrows to Switch Between Settings, and the Up and
Down Arrows to Adjust Settings. (Material with Laminate is Cut at 090
Press, Vinly Material is Cut at 060 press) To Lock in Settings, Press the
Icon All the Way to the Right Using the Right Arrow Button.
8. Press Remote

Fine Cut 8
1. Highlight cut lines and register marks
2. Open Fine Cut 8
3. Register mark > Detect mark
4. Plot > Plot to begin cutting
5. Press remote to check depth, adjust depth by clicking tool and
adjusting
6. Press remote to resume cutting

You might also like