Professional Documents
Culture Documents
p0011 Testing
p0011 Testing
P0011
Procedures
Use only gold-plated terminals when servicing terminals in the electrical harness
connectors of the Camshaft Adjustment Valve 1 N205.
Multimeter.
Wiring diagram.
Test requirements
Vehicles with automatic transmission, shift selector lever into position "P" or "N".
A/C switched off.
Ground (GND) connections between engine/transmission/chassis OK.
Ignition switched off.
Test procedure
Start diagnosis
Fig 1: Identifying CMP Sensor G40, CMP Sensor 2 G163 And Connectors
Using a Multimeter , check the Camshaft Adjustment Valve 1 N205 electrical terminals 1
to 2 for resistance.
Checking voltage
Check the Camshaft Adjustment Valve 1 N205 electrical harness connector terminal 1 to
the Motronic Engine Control Module (ECM) Power Supply Relay J271 socket 2/87 for
an open circuit, short circuit to Battery (+) or Ground (GND).
Check the electrical harness connector for damage, corrosion, loose or broken terminals.
If necessary, repair the faulty wiring connection.
Checking wiring
If the manufacturers test box is being used. Perform the following step.
If the manufacturers test box is not being used. Perform the following step.
Using a Multimeter , Check the Camshaft Adjustment Valve 1 N205 electrical harness
connector terminal 2 to the Motronic Engine Control Module (ECM) J220 electrical
harness connector for resistance.
Camshaft Adjustment Valve 1 N205 Motronic Engine Control Module (ECM) J220
electrical harness connector terminal electrical harness connector terminal or test box socket
2 115
Specified value: 1.5 Max.
Check the wiring connection for an open circuit, short circuit to Battery (+) or Ground
(GND).
Check the electrical harness connector for damage, corrosion, loose or broken terminals.
If necessary, repair the faulty wiring connection.
End diagnosis.
If the DTC does return and no malfunction is detected in the wiring and the Ground activation
was not OK:
Final procedures
After repair work, the following work steps must be performed in the following sequence:
End of diagnosis.