INSIDE DIMENSIONS: OUTER L - 20-1/4" 3/4" EXT. PLWD. W - 16-5/8" COVER W/TIN The species of wood used to COVER D - 1-1/2" make a beehive can vary 2-1/4"
depending upon what is
available in your area. The INNER " 21-3/4" 18-1/8 minimum thickness should not COVER 1/4" PLYWD. be less than 3/4". If you are 2" 1-1/4" X 3-1/ 3/4" 5/8" HOLE using standard dimensional " lumber, you can use 1x8 (3/4" x 19-7/8" 16-1/4 SHALLOW 7-1/4") for both shallow and SUPER medium super, and 1x12 (3/4" x 5-11/16" 11-1/4") for the deep hive body. 5-11/16"
Start by cutting the boards to
length. For fronts and backs, " cut them a smidgen over 16- 19-7/ 1/4 8" 16- 1/4". For sides, cut a smidgen DADANT (MEDIUM) over 19-7/8". At this point, HONEY SUPER follow the steps described on 6-5/8" how to make a box joint from the PDF Box Joint files. 6-5/8"
Now that you have the joint cut
" and the boards cut to finished 19-7/ 1/4 3/8" 3/4" 8" 16- size, cut the 5/8" x 3/8" rabbet on the 16-1/4" boards stopping 3/4" just short of the box joint pin at BEST DETAIL 5/8" 3/8" " OF FRAME each end. (Chisel these square 5/8 REST INSIDE DIMENSIONS: after the boards are OPTION L - 18-3/8" W - 14-3/4" assembled). Note detail of DEEP D - 9-5/8" frame rest at left. Pre-drill holes HIVE BODY for nails in each pin.
Assemble boxes with glue and
9-5/8"
nail each pin with a 6d galv.
PRE-DRILL & NAIL nail. Attach 1x2 handholds with W/ 6d GALV. screws and glue. Attach metal " rabbets on the frame rest 19-7/ 1/4 notch. Fill any holes and paint 8" 16- all surfaces, both outside and 3/4" x 2" CLEAT inside and top and bottom BOTTOM FOR HANDHOLD BOARD edges, with two coats of paint. " 1-7/8 " 3/8 1/4" 22-0 " 16- '.1999.BeeSource.com - All Rights Reserved. info@beesource.com/www.beesource.com 3/4" EXT. PLWD. Reproduction for personal and non-profit use only.