The document describes the functions of various controls on an oscilloscope. It lists controls for selecting the sync signal source, such as the internal channel A and B signals, external trigger, or power line waveform. It also lists vertical controls for channel B including position, invert, volts/div, and the vertical input. Additional controls adjust the focus, intensity, sweep time/div, and trace rotator.
The document describes the functions of various controls on an oscilloscope. It lists controls for selecting the sync signal source, such as the internal channel A and B signals, external trigger, or power line waveform. It also lists vertical controls for channel B including position, invert, volts/div, and the vertical input. Additional controls adjust the focus, intensity, sweep time/div, and trace rotator.
The document describes the functions of various controls on an oscilloscope. It lists controls for selecting the sync signal source, such as the internal channel A and B signals, external trigger, or power line waveform. It also lists vertical controls for channel B including position, invert, volts/div, and the vertical input. Additional controls adjust the focus, intensity, sweep time/div, and trace rotator.
The document describes the functions of various controls on an oscilloscope. It lists controls for selecting the sync signal source, such as the internal channel A and B signals, external trigger, or power line waveform. It also lists vertical controls for channel B including position, invert, volts/div, and the vertical input. Additional controls adjust the focus, intensity, sweep time/div, and trace rotator.
HF REJ: Low Pass Filter cuts off RF composite of the sync signal.
TV: TV or Video composite signis are easily triggered.
SWEEP TIME/DIV selects TV-V (50/sec~0.1 msec) or TV-H (50/isec~02/isec) 17. GND Ground terminal. 18. SOURCE Sync signal selector. INT: CH-A and CH-B signis are added on for triggering. CH-A: Sync signal for triggering comes only from CH-A. But, when in single sweep, the channel selected by MODE has priority. CH-B: Signal from CH-B. The rest is the same as CH-A. LINE: AC power Une waveform is used as sync signal source. EXT: The signal hooked into EXT TR1G becomes the sync signal source. 19. POWER SWITCH Tums power on or off. 20. FOCUS Focus control to obtain optimum waveform display. 21. INTENSITY Adjust the brightness of waveform for easy viewing.
SECTION 3 OPERATION
22. TRACE ROTATOR
The earth magnetics effect the trace line. Rotate this with a screw driver for proper trace line. 23. CH-B POS1TION, PULL INVERT CH-B vertical position control. When pulled, the CH-B vertical polarity is inverted. This facilitatesSUB MODE measurement at ADD MODE. 24. VOLTS/DIV Vertical attenuator for CH-B. 25. VARIABLE 26. VERTICAL INPUT