Professional Documents
Culture Documents
Procedure
Procedure
Procedure
1. Connect 4v (rms) AC source across the series resistor as shown in the figure
4Vrms
60 Hz
00
2. Measure the voltage across the 470- resistor and the current through it
VRT =
LRT =
3. Connect channel 1 of the oscilloscope across point and 2 (i.e across the 470-) and channel 2 to
the 10- resistor
4. Draw the corresponding waveform, the voltage across the 470 and the voltage across the 10
resistor. Assuming that the v voltage across the 10- resistor is the current, determine the
phase relationship between voltage and current in a resistive circuit
5. In the circuit shown in figure 3.1 adjust the frequency to 100 Hz. Measure the voltage across the
470- resistor and the current through it
6. Repeat procedure 5 by adjusting the frequency to 200hz , 400hz, 600hz, 800hz, and 100hz.
7. Plot a graph of resistance against the frequency