The document provides instructions for erasing the memory of a 7D1-40 transfer control system. The 8-step procedure involves preparing short harness needles, turning the ignition on and off to confirm a relay sound, and checking that the "Check 4WD" lamp turns off after erasure. Technicians are advised to check circuits are normal before erasing memory.
The document provides instructions for erasing the memory of a 7D1-40 transfer control system. The 8-step procedure involves preparing short harness needles, turning the ignition on and off to confirm a relay sound, and checking that the "Check 4WD" lamp turns off after erasure. Technicians are advised to check circuits are normal before erasing memory.
The document provides instructions for erasing the memory of a 7D1-40 transfer control system. The 8-step procedure involves preparing short harness needles, turning the ignition on and off to confirm a relay sound, and checking that the "Check 4WD" lamp turns off after erasure. Technicians are advised to check circuits are normal before erasing memory.
1. Prepare two pieces of short harness with the end sharped like a needle (bout 20cm(7.9 in) long). 2. Turn OFF the ignition. 3. Remove the front left seat ASM. 4. Make the controller under the front left seat ASM (spread the cut of the floor carpet).
5. Keeping the connector of the transfer controller connected,
set the short harness from the back of the connector as illustrated. 6. Turn ON the ignition, wait for 2 seconds, and turn OFF the ignition after confirming the relay sound. 7. Disconnect the short harness, turn ON the ignition again, and confirm the Check 4WD lamp in the meter panel is OFF. 8. Before erasing the memory, check that the circuit of the T/F actuator position detection harness, etc. for it are normal.