This lantern-style lamp and shoji 3. Dry fit the four frames, mark ventilation and access space on the screen can be used indoors or out. them, and drill holes for doweling other side. It's constructed easily with glue them together. Then sand and fin 7. Lace the lamp cord through the and small brads; however, remem- ish the frames as desired. holes and channel in the two ber to nail carefully to avoid split- 4. Cut a piece of fiberglass fabric frames, pulling enough out the ting the wood. large enough to cover the rectan upper end for connecting with the 1. After cutting all the pieces to gular opening in each frame. Fas socket. Fasten the four frames to size, assemble the frames by attach ten the fiberglass panels to the gether using glue and dowels. Then ing the rails (B) to the legs (A) with inner face of each frame using glue and tack the support strips (D, dowels and glue. Place the rails small wire nails. E) to the backs of the upper rails, 3/4" down from the tops of the legs 5. Drill a hole through the base keeping their lower edges flush. and 6-3/8" up from the bottoms as (C), centered along its length and 8. Insert the pipe nipple into the shown. 1-1/2" from one side. Size the hole base, keeping the nut on the lower 2. Rout a 6-1/4"-long channel up to accept the pipe nipple found in end. Run the cord up through the the center of one of the legs, be the lamp socket kit. nipple and fasten it to the socket, ginning at the bottom. Make the 6. Fasten the base between the then mount the socket on the nip channel wide and deep enough to frame with the cord channel and ple. Rotate the socket to place the enclose the lamp cord and place it one other frame using dowels and pull chain side next to the ventila on an outside edge that can be cov glue. Make the base side that is tion hole, then tighten the nut. ered by an overlapping frame as farthest from the pipe nipple hole 9. Cut a piece of fiberglass to serve shown in the drawing. Then, on flush with the outside edges on as the top of the lamp. Glue and the adjacent inside face of the leg, one side of the frames to create a tack it to the top edges of the sup drill a hole that intersects the upper port strips. end of the channel to provide an exit for the cord. Pick the frame that will cover the cord channel and drill a hole through it near the bottom of the appropriate leg to provide an entry path for the cord.