Here's a handsome pedestal to display your favorite plant. The original was made 7. Round or bead the upper edges of clear grade redwood. The wider pieces of the top (E), then center the were glued up from narrower stock and apron pieces on the underside of custom cut to the dimensions listed. the top. Glue and screw through 1. Cut all of the pieces to size ac the apron into the top. cording to the dimensions given. 8. Center the bracket (F) on the 2. Cut three plug holes in each col column; then glue and screw it in umn side (A) as shown. Locate the place. Center the top/apron as holes 2-1/2" from each end, with sembly on the bracket; glue and the remaining hole in between. All screw through the bracket into the of the holes should be centered apron. 3/8" from one edge of the piece. 9. Round or bead the upper edges 3. Drill pilot holes for the wood of the base pieces (B, C) and feet screws in the center of the plug (D); then sand. holes. 10. Center the small base piece on 4. Assemble the column by gluing the bottom of the column. Glue and screwing one corner at a time. and screw it in place from under Be sure that the assembly is square. neath. Repeat with the large base 5. Round the edges of the column piece. by sanding or routing with a 1/4" 11. Position the feet so they ex radius bit. tend beyond the corners of the 6. Cut 45 miters at the corners of base as shown; secure with glue the apron pieces (G). and screws. 12. Sand the completed plant stand; finish as desired.