Professional Documents
Culture Documents
The Mini Extruder: 1. Lid. 2. Base
The Mini Extruder: 1. Lid. 2. Base
Ice cold water is pumped and circulated thru the cooler plates that are in direct contact with
the dough.
Detail Description
The LID
This is straight forward.
Here are the photos.
The WATERWAY is the outer cover (the outer surface will be covered unlike the photo)
Again the photo illustrates the design only and as explained 3D cannot print the water ways. (May be
the technology has advanced)
The BASE
This is again straight forward.
Here are the photos.
The WATERWAY is the under surface (will be covered unlike the photo)
There is an extra component here called the SPACER. This is to add a little volume between the Lid
and Base.
Dough is pumped under low pressure from the inlet.
The Dough is extruded from the SPLIT a 1mm gap tip 63mm wide.
SPLIT