This document provides information for calculating the summer cooling load for Office two in the Building No. one West wing project. It includes dimensions of the office, outside weather conditions, internal heat gains, transmission heat gains, and calculations of the sensible and latent heat loads. The total calculated cooling load for the office is 18,078 BTU/hr or 1.51 tons.
This document provides information for calculating the summer cooling load for Office two in the Building No. one West wing project. It includes dimensions of the office, outside weather conditions, internal heat gains, transmission heat gains, and calculations of the sensible and latent heat loads. The total calculated cooling load for the office is 18,078 BTU/hr or 1.51 tons.
This document provides information for calculating the summer cooling load for Office two in the Building No. one West wing project. It includes dimensions of the office, outside weather conditions, internal heat gains, transmission heat gains, and calculations of the sensible and latent heat loads. The total calculated cooling load for the office is 18,078 BTU/hr or 1.51 tons.
2 Project Name : Building No. one West wing Altitude 600 Mt Latitude 30 Estimated by Ghaleb Abu 3 Date July 28, 2000 Saa' 4 Reference Dimensions Space used for Lb H2O/Lb dry air 5 Unit L W H Area Volume Office Outside Room 6 Office two Ft 17 22 10 376 3,696 Special conditions 0.0122 0.0104 7 Mt 5.25 6.65 3.00 34.91 104.74 Temp. not to exceed 74 oF Grains/Lb H2O 6000 8 Summer Cooling Load NOTES 9 Condition Unit DB WB %RH Gr/Lb SUN LIGHT GAIN 10 oF 115 84 29% 126 1 For rooms or zones having more than one exposure, use north Outside 11 oC 46 28.9 29% 126 values for all exposures except the one having the largest solar 12 oF 70 50.0 50 38 gain. Usually greatest solar area. Inside 13 oC 21 10.0 50 38 2 Figures shown are based on an average of 17 Hrs operation. 14 oF 45 88 3 Multiply by factor 1.2for very light construction, 0.9 for very Difference 15 oC 25 88 heavy construction & 1.25 for hotels to allow for pull-down & 16 Outside Air/Fresh air data individual rooms preference on outside air temperature. 17 Variable Qty Total Air changes per % to A/C TRANSMISSION GAIN 18 Persons 2 CFM Hr CFM 1 Ceiling type one is under finished room 19 CFM/Person 15 30 0.49 4.05% 2 Ceiling type two is un-insulated frame or heavy masonary with ceiling 20 Room heat load 3 Ceiling type three is un-insulated frame or heavey masonery 21 Sensible heat load without ceiling 22 Sun light gain BTUH 1,824 4 Ceiling type four is un-insulated light masonary with ceiling 23 Sourse Sq Ft Factor BTUH W1 5 Ceiling type five is un-insulated light masonary without ceiling 24 Glass N 0 23 0 169 6 Ceiling type six is insulated all kinds with ceiling 25 Glass E 0 80 0 7 Ceiling type seven is insulated all kinds without ceiling 26 Glass S 0 68 0 8 Floor type one is over finished floor 27 Glass W 19.4 94 1823.6 W3 215 215 W4 9 Floor type two is over basement with finished ceiling 28 Glass NE 0 66 0 10 Floor type three is on ground. 29 Glass SE 0 70 0 W3 Safety Factors 30 Glass SW 0 81 0 W2 Glass SAFETY FACTOR "A" 5% 31 Glass NW 0 74 0 169 19.4 Re-heat supply duct heat gain 5% 32 Transmission heat gain BTUH 10,357 1 Supply duct leakage loss 2% 33 type Sq Ft u To-Ti BTU/Hr Fan factor 3% 34 Sunlit walls 150 0.3 45 2,026 Safety factor used 5% 35 Shaded wall 0 0.2 0 0 SAFETY FACTOR "B" 2% 36 Partition 169 0.2 45 1,525 2 Supply duct leakage loss 2% 37 Ceiling type one 0 0.24 0 0 Safety factor used 2% 38 Ceiling type two 0 1.07 0 0 SAFETY FACTOR "C" 0% 39 Ceiling type three 0 1.2 0 0 Return duct heat gain 2% 40 Ceiling type four 0 1.6 0 0 Return duct leakage gain 3% 3 41 Ceiling type five 0 1.7 0 0 Pump Hp 2% 42 Ceiling type six 376 0.2 45 3,380 Dehumidufication & piping loss 3% 43 Ceiling type seven 0 0.9 0 0 Safety factor used 0% 44 Floor type one 376 0.24 38 3,425 Latent heat load 45 Floor type two 0 0.2 0 0 Sourse No. Factor BTU/Hr 46 Floor type three 0 0 0 0 people seated at rest 0 150 0 People seated, very light 47 Internal heat gain BTUH 1,663 2 155 310 work 48 Sourse No. Factor BTU/Hr People moderately active 0 250 0 Standing light work/walking 49 people seated at rest 0 180 0 0 300 0 slowly Sedentary & light bench 50 People seated, very light work 2 193 386 0 330 0 work. 51 People moderately active 0 200 0 Moderate & heavy work. 0 980 0 52 Standing light work/walking slowly 0 200 0 Steam rate in Lb/Hr 0 1000 0 53 Sedentary & light bench work. 0 220 0 Room latent heat sub total 310 54 Moderate & heavy work. 0 450 0 Safety factor "B" 1.02% 55 Motors in KW 0 3412 0 Room latent heat 316 56 Lights in Watt 376 3.4 1,277 Outside air heat load 57 Room sensible heat sub total 13,843 Sensible heat CFM Delta "T" Factor BTU/Hr 58 Safety factor "A" 1.05% 30 45.0 1.08 1,458 59 Room sensible heat 14,535 Latent CFM "Gr/Lb" Factor BTU/Hr 60 Grand total sensible heat 15,993 30 88 0.67 1,769 61 Room total heat load BTUH 18,078 Safety factor "C" 1.00% 62 Q = mCpDelta"T" Tons 1.51 Out side air total sensible heat load 1,458 63 (1.2*2.2/35)*60*0.24*Delta "T" KW 5.30 Out side air total latent heat load 1,769 64 1.077 Kcal/Hr 4,535 Grand total latent heat 2,085 Assume delta "t" (temperature difference between room temperature & air off coil dry bulb temperature to 65 oF 20 be :- 66 740